Abstract:The aeroelastic response of lightweight low-speed aircrafts with slender wings under extreme flow turbulence intensity is not well understood. Experiments on a commercial unmanned aerial vehicle (UAV) with a 3 m wingspan and aspect ratio of 13.6 were performed in a large open-return wind tunnel with extreme flow turbulence intensity of ≈10%. The wing bending displacement and the flow beneath the wing were measured by using laser-displacement sensors and tomographic particle image velocimetry (PIV) techniques, respectively. The unsteady lift produced by the wing was also measured by using a high-capacity load cell at an angle of attack of two degrees for three freestream velocities of 13.4 m/s, 17.9 m/s, and 26.8 m/s, representing the UAV's stall speed, a speed approximately equal to the cruise speed, and a speed considerably higher than the cruise speed, respectively. It was found that a high flow turbulence intensity with large integral length scales relative to the wing chord plays a dominant role in the large unsteady lift and wing displacements measured. The power spectral density (PSD) of the wing structural vibration shows that flow shedding from the wing and the integral length scales have a significant impact on the overall power inherent in the bending vibration of the wing. Computations of the vorticity isosurfaces in the flow measurement volume surrounding the aileron reveal a striking observation: an aileron deflection of 10° becomes less effective in producing additional spanwise vorticity, which is proportional to circulation and lift at 26.8 m/s since the freestream already has elevated levels of vorticity. A paradigm shift in design is suggested for light aircraft structures with slender wings operating in highly turbulent flow, which is to employ multiple control surfaces in order to respond to this flow and mitigate large bending or torsion displacements and the probability of structural failure.

Numerical Modeling and Analysis of Wing Rock in SACCON UCAV

Numerical research on rock characteristic about a slender delta-wing

Nonlinear Analysis of Dynamic Stability and the Prediction of Wing Rock

Bifurcation analysis of wing rock and routes to chaos of a low aspect ratio flying wing

Prediction and suppression of wing rock using bifurcation analysis

Experimental Investigation on Limit Cycle Wing Rock Effect on Wing Body Configuration Induced by Forebody Vortices

Modeling of Wing Rock Using Frequency Spectrum Analysis to Free-to-Roll Time History

Mechanism Analysis of Hysteretic Aerodynamic Characteristics on Variable-Sweep Wings

Adaptive Fuzzy Control of Aircraft Wing-Rock Motion

Numerical Research on Roll and Sideslip Coupling Motions About a Slender Delta-wing

Delta wing rocking motion suppression by deep reinforcement learning

Unsteady aeroelastic characterization and scaling relations of flexible membrane wings

Nonlinear dynamic analysis of aircraft CFRP sandwich wings under explosive blast loading: Introducing SVM-DNN algorithm to predict dynamical information

A Shear-Sliding Rigid-Flexible Coupled Skin Variable-Sweep Wing Design and Heat-Fluid-Structure Multifield Coupling Analysis

Experiments of Lift-Bending Response on a Slender UAV Wing Structure with Control Surface under Extreme Flow Turbulence

Robust aeroelastic instability suppression of an advanced wing with model uncertainty in subsonic compressible flow field

Resolvent analysis of a finite wing in transonic flow

Calculation of flutter and dynamic behavior of advanced composite swept wings with tapered cross section in unsteady incompressible flow

Study of Dynamic Interaction Between Low Re Aerodynamic Load and Flexible-Biomimetic Wings with Tailorable Stiffness by FSI Modeling

Aeroelastic Instability and Response of Advanced Aircraft Wings at Subsonic Flight Speeds

Aerodynamic Analysis and Simulation for a Z-Shaped Folding Wing UAV