Abstract:Hydrocyclone separation technique has commonly been applied in engineering for solid-liquid separation. In aquaculture, since Hydrodynamic Vortex Separator (HDVS) is able to control flocs concentration effectively, the Recirculating Biofloc Technology (RBFT) has been gradually acknowledged (Zhu et al., 2016). In order to operate RBFT system at maximum performance, the removal efficiency of HDVS at different Hydraulic Retention Time (HRT) must be fully predictable. The aim of this work is to investigate the relationship between separation efficiency and HRT of HDVS applied in RBFT system, through Computational Fluid Dynamics (CFD) method. For this, a three-dimensional unsteady transient model was developed to simulate the hydrodynamics in HDVS based on the commercial software Workbenching 17.0. A Two Fluid Model (TFM) using kinetic theory of granular flow (KTGF) has been developed to describe the dense solid-liquid (flocs-water) flow field of HDVS in RBFT system. Additionally, the Reynolds averaged Navier-Stokes (RANS) equations with Reynolds stress turbulence model (RSM) are solved by use of the finite volume method based on the SIMPLE pressure correction algorithm in the computational domain. Finally, pilot-scale studies were conducted to evaluate the accuracy and precision of simulation models applied. The results indicate that the flocs removal efficiency of HDVS obtained from tests were less than that from the simulation results at three different HRTs. But it decreased with the decline of HRT both for experiment and simulation. Additionally, the CFD model proposed can enhance the fundamental understanding of the effects of HRT on separation efficiency and at the same time, probably coupled with physical experiment whenever necessary, offer a more reliable way for optimum control of HDVS under varying conditions. Based on the simulation results, the flocs management in RBFT system is briefly discussed.

Experimental and Numerical Investigation on the Disinfection Characteristics of a Novel Rotor-Radial Groove Hydrodynamic Cavitation Reactor

Disinfection characteristics of an advanced rotational hydrodynamic cavitation reactor in pilot scale

Cavitation characteristics analysis of a novel rotor-radial groove hydrodynamic cavitation reactor

Numerical Verification for a New Type of UV Disinfection Reactor

Numerical Study of Dense Solid-Liquid Flow in Hydrodynamic Vortex Separator Applied in Recirculating Biofloc Technology System

Study on the characteristics of cavitation and COD removal of an addendum rotational hydrodynamic cavitation reactors

Investigation on the Cavitation Characteristic of a Novel Cylindrical Rotational Hydrodynamic Cavitation Reactor

Experimental and Numerical Study of Cavitating Flow with Suction in a Mixing Reactor for Water Treatment

Hydrodynamic cavitation as a promising route for wastewater treatment - A review

Effect of Disturbing Flow Ring on Hydrodynamic Cavitation Characteristics of Self-Excited Oscillating Cavitation Used for RB Degradation

Ozonation degradation of wastewater using rotational hydrodynamic cavitation reactor with a conical rotor

Optimization of Microwave Induced Electrodeless Ultraviolet Disinfection Reactor Using Computational Fluid Dynamics

Simulation and Experimental Investigation of an Ultrasound System with Cavitation in Concentric Zone

Numerical investigation of effect of geometric parameters on performance of rotational hydrodynamic cavitation reactor

Spatiotemporal Evolution of Rotational Natural Cavitation in Rotational Supercavitating Evaporator for Desalination

Experimental Study of Decomposition of Rhodamine-B by Hydrodynamic Cavitation Technique

Investigations on cavitation flow and vorticity transport in a jet pump cavitation reactor with variable area ratios

Research of a Novel Counter Rotating Hydrodynamic Cavitation Device Applied for Ballast Water Treatment

Application of hydrodynamic cavitation in the field of water treatment

Research progress of hydrodynamic cavitation reactors in the field of water treatment: A review

PRELIMINARY STUDY ON THE DYIEING WASTEWATER TREATMENT BY HYDRODYNAMIC CAVITATION TECHNIQUE