Abstract:Proceedings of the Institution of Mechanical Engineers, Part C: Journal of Mechanical Engineering Science, Ahead of Print. Due to the exist of the inevitable dimensional tolerance and assembling errors in the ball bearing, the interference amounts between the inner ring and the connected shaft are uncertain but bounded, which could directly affect the dynamics performance of the rotor-ball bearing system. Whereas, most of the works on the field of dynamics in a ball bearing have considered the varying compliance (VC) vibration as deterministic vibration and there are few quantitative studies considering the uncertain factors. Therefore, in this paper, an uncertain ball bearing-rotor dynamic model is presented based on the Chebyshev interval method. Firstly, the uncertain interference amounts between the bearing inner ring and the connected shaft are modeled by the Chebyshev interval method. Then the radial clearance and actual interference amounts of ball bearing are derived by the bearing-shaft interference fit model. The time-dependent ball-raceway contact probability is formulated and the influence of the average and deviation coefficient of the initial interference amounts on the vibration behaviors of the rotor under various rotational speeds are investigated based on the double degrees of freedom (2-DOF) ball bearing system. The numerical cases show that the amounts of the bearing-shaft interference fit are uncertain and could be affected by rotational speed, which have an obvious influence on the dynamic performance of the rotor-ball bearing system. Reasonable design of the interference amounts could reduce the dispersion of the displacement and time-varying stiffness. The numerical results obtained by the present study are compared to the Monte Carlo simulation (MCS), which show the validity of the study.

The Effects of Interval Uncertainties on Dynamic Characteristics of a Rotor System Supported by Oil-Film Bearings

Review of Nonlinear Rotor-Bearing Dynamics System

Modeling a Two-Span Rotor System Based on the Hamilton Principle and Rotor Dynamic Behavior Analysis

Dynamic Response Analysis of a Shaft-Disk-drum Rotor System with Interval Uncertainties

Dynamic Behavior Analysis of a Rotor-Bearing-Squeeze Film Damper Coupling System with Bearing Outer Race Localized Defect

Dynamic Analysis of Geared Rotor System with Hybrid Uncertainties

Nonparametric Modeling and Vibration Analysis of Uncertain Jeffcott Rotor with Disc Offset

Lubrication and stability analysis of nonlinear rotor-bearing system

Research on the vibration characteristics of the ball bearing considering the uncertain bearing-shaft interference fit

Dynamic characteristics analysis of an elliptical bearing-rotor coupled system

Periodic, quasi-periodic and chaotic vibrations of a rub-impact rotor system supported on oil film bearings

Study on the influence of joint parameters on nonlinear dynamics of a rotor system

Propagation of Uncertainty in Experimental Dynamic Coefficients of Fluid Film Journal Bearings

Dynamics Analysis Control on Dual Delay Bearing-Rotor System

Nonlinear Dynamic Analysis of a Rotor/bearing/seal System

Dynamic modeling and reliability analysis of the ball bearing rotating accuracy considering the uncertain bearing-shaft interference fit

Investigation on the dynamic behaviors of a rod fastening rotor based on an analytical solution of the oil film force of the supporting bearing

Modeling and Nonlinear Dynamic Characteristics Analysis of Fault Bearing Time-Varying Stiffness-Flexible Rotor Coupling System

Nonlinear responses of a dual-rotor system with rub-impact fault subject to interval uncertain parameters

Nonlinear dynamic of flexible rotor supported by turbulent bearings with quadratic damping and temperature dependent viscosity

Transient nonlinear dynamics of the rotor system supported by low viscosity lubricated bearing