Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Investigation of Single Drop Evaporation Characteristics of Two-Component Fatty Acid Methyl Esters at High Temperature

Evaporation of high-volatile binary sessile drop: Influence of concentarion

Experimental Study on Evaporation Characteristics of Methyl Oleate Droplet Across Critical Pressure and Temperature Environments

AN EXPERIMENTAL STUDY OF EVAPORATION,MICROEXPLOSION AND IGNITION OF DROPLETS ON HOT SURFACE

The investigation of evaporation behavior of lubricating oil droplet at high ambient temperature

A molecular dynamics study of evaporation of multicomponent stationary and moving fuel droplets in multicomponent ambient gases under supercritical conditions

Molecular Dynamics Study of Binary Nanodroplet Evaporation on a Heated Homogeneous Substrate

Droplet Evaporation to Boiling in Van Der Waals Fluid

Experimental and Theoretical Investigation of Contact-Angle Variation for Water–ethanol Mixture Droplets on a Low-Surface-energy Solid

Molecular Dynamics Simulations on Evaporation of a Suspended Binary Mixture Nanodroplet

Effect of droplet sizes on evaporation of a bi-component droplet at DME (dimethyl ether)/n-heptane-fueled engine conditions

Effect of ambient temperature and water content on emulsified heavy fuel oil droplets evaporation: Evaporation enhancement by droplet puffing and micro-explosion

A molecular dynamics study of evaporation mode transition of hydrocarbon fuels under supercritical conditions

Experimental Investigation Evaporation Of Liquid Mixture Droplets During Depressurization And Into Air Stream

Experimental Study of Evaporation Characteristics of Acoustically Levitated Fuel Droplets at High Temperatures

Experimental investigation of liquid thermal diffusivity for fatty acid methyl/ethyl esters by dynamic light scattering method

Experimental Investigation on Evaporation of a Single Droplet Levitated in Acoustic Field

On evaporation dynamics of an acoustically levitated multicomponent droplet: evaporation-triggered phase transition and freezing

Evaporation Investigation of Single Droplet in High Temperature Fuel Gas

An experimental study of the vaporization, micro-explosion and ignition of single droplet on hot surface

Experimental Investigation of Dynamic Evaporation Characteristics of Liquid Droplet on Heated Surface