Abstract:Dielectric ceramics with low permittivity (epsilon(r)), high quality factor (Qxf), and near-zero resonant frequency (tau(f)) in the microwave bands are key materials used in fifth/sixth-generation (5G/6G) telecommunication, while tau(f) of most low-epsilon(r) microwave dielectric ceramics is relatively negative. In this work, the first low-epsilon(r) Ga-based ceramic SrGa12O19 with an anomalous positive tau(f) was reported, and the causes of the positive tau(f), intrinsic polarization, and loss mechanism were systematically studied. X-ray diffraction (XRD) and transmission electron microscopy (TEM) revealed that the SrGa12O19 ceramic formed a pure hexagonal magnetoplumbite structure with spinel blocks and rock-salt blocks stacked along the crystallographic c-axis. When sintered at 1430 degrees C, it possessed the optimal microwave dielectric properties of a low epsilon(r) of 14.46, high Qxf of 64,705 GHz, and exceptional positive tau(f) of +55.7 ppm/degrees C, along with a low linear thermal expansion coefficient (alpha(L)) of 11.617 ppm/degrees C. The large positive deviation between epsilon(r) and epsilon(r(C-M)) of 45.31% resulted from the rattling effect of atoms in the rock-salt block. The unique positive tau(f) (+55.7 ppm/degrees C) was governed by the rattling effect, resulting in a positive tau(alpha m) (the temperature coefficient of ion polarizability) of 8.489 ppm/degrees C and a large negative temperature coefficient of permittivity (tau(epsilon)) of -132.864 ppm/degrees C. Phillips-Vechten-Levine (P-V-L) chemical bond theory revealed greater contributions of the spinel block to bond ionicity (f(i), 52.95%), permittivity (epsilon, 55.15%), bond energy (E, 56.87%), and lattice energy (U, 74.88%) than those of the rock-salt block. The intrinsic dielectric properties were analyzed using infrared (IR) reflectivity spectra. The favorable performance of the SrGa12O19 ceramic indicated that it is a novel tau(f) compensator. This selection of compounds with different structural layer combinations provides a new idea for exploring excellent microwave dielectric ceramics.

Ultra-low Permittivity MgF2 Ceramics with High Qf Values and Their Role As Microstrip Patch Antenna Substrates

Novel low-er MGa<sub>2</sub>O<sub>4</sub> (M = Ca, Sr) microwave dielectric ceramics for 5 G antenna applications at the Sub-6 GHz band

Low-temperature Co-Fired Ceramics with High Thermal Expansion and Reliability for Millimeter-Wave Antennas

Unleashing the Potential of Mg2SiO4-based Ceramics for Millimeter-Wave Applications: Achieving Ultra-Low Loss with Enhanced Temperature Stability Through Heterovalent Ion Substitution

Novel ultra-low loss and low-fired Li8MgxTi3O9+xF2 microwave dielectric ceramics for resonator antenna applications

Low permittivity cordierite-based microwave dielectric ceramics for 5G/6G telecommunications

SrGa12O19: the First Low-Εr Ga-based Microwave Dielectric Ceramic with Anomalous Positive Τf

MgF 2 -based microwave dielectric ceramics with ultra-low sintering temperature and high thermal expansion coefficient

Microwave Dielectric Properties of Mg1.8R0.2Al4Si5O18 (R = Mg, Ca, Sr, Ba, Mn, Co, Ni, Cu, Zn) Cordierite Ceramics and Their Application for 5G Microstrip Patch Antenna

Cold sintering optimized SrF2 microwave dielectric ceramics for the development of dielectric resonator antenna at 5G millimeter-wave band

High quality factor cold sintered LiF ceramics for microstrip patch antenna applications

Cold sintering optimized LiF microwave dielectric ceramics for the development of dielectric resonator antennas at 5G millimeter-wave band

Emerging magnetodielectric materials for 5G communications: 18H hexaferrites

Low temperature sintered MgO–based microwave dielectric ceramics with ultra‐low loss and high thermal conductivity

Β-Ga2o3: Ultralow-Loss and Low-Permittivity Dielectric Ceramic for High-Frequency Packaging Substrate

Design and fabrication of a C-band patch antenna using novel low permittivity SrGa2Si2O8 microwave dielectric ceramic

A Microwave Dielectric Ceramic with Ultra-low Dielectric Constant Prepared by Reaction Sintering Method

High-Qf value and temperature stable Zn2+-Mn4+ cooperated modified cordierite-based microwave and millimeter-wave dielectric ceramics

High Q×f values of Zn-Ni co-modified LiMg0.9Zn0.1-xNixPO4 microwave dielectric ceramics for 5G/6G LTCC modules

Enhanced microstructure and dielectric properties of low-temperature sintered MgO-xwt%LiF ceramics for high-frequency applications

High Quality Factor, Ultralow Sintering Temperature Li6B4O9 Microwave Dielectric Ceramics with Ultralow Density for Antenna Substrates