Abstract:AlN is deposited on silicon carbide (SiC) for high-power electronics; in these devices, AlN acts as both a buffer layer for the growth of the active device and a thermal conductor. However, the mechanism of thermal transport through the AlN-SiC interfaces and through grain boundaries of AlN has not been clearly analyzed, even though AlN forms grain boundaries during the deposition process. The thermal properties of the AlN-SiC interface and the inversion domain boundaries (IDBs) of AlN were examined by a phonon transport model based on a nonequilibrium Green function formalism and first-principles calculations. The interface and grain boundary models were designed, and the thermal resistances (TRs) and origins of TR were examined. The TRs of the AlN-SiC interface and the IDB of AlN are much higher than the TRs of AlN and SiC of relevant thickness. Elemental intermixing and vacancy formation were modeled. The formation of charge-balanced defect of VAl + 3ON is thermodynamically favorable compared to other defects, indicating that ON induces formation of VAl. The charge-balanced defect combining VAl and ON increases the TRs of both AlN-SiC interfaces and AlN grain boundaries because vacancy defects induce larger changes in mass than all other defects, and TRs are proportional to changes in mass. In addition, VAl defects are increased by excess ON, resulting in a continuous increase in TR, and then, the calculated thermal boundary resistance (TBR) of the AlN-SiC interface with increased density of VAl by excess ON reaches the experimental TBR. Therefore, it is expected that the large increase in TR by the formation of VAl + ON would be suppressed by controlling the low O density during synthesis.

Establishment and Verification of Resistance Temperature Coefficient Model of P-type Non-Uniformly Doped Resistance

Measurement of Electron-Density and Mobility in P-Doped A-Si-H and Mc-Si-H Films

Piezoresistive Thermal Characteristics of Aluminum-Doped P-Type 3C-Silicon Carbides

The piezoresistive mobility modeling for cubic and hexagonal silicon carbide crystals

Study on the influence of doping process on resistance of semiconductor bridge region

Oxide Precipitate Nucleation at 300 °C in Low Resistivity N-Type Czochralski Si

Numerical Simulation of a Novel Method for PVT Growth of SiC by Adding a Graphite Block

A Unified Mobility Model for Cryogenic Bulk Silicon Simulations in Wide Doping Range

Contactless determination and parametrization of charge carrier mobility in silicon as a function of injection level and temperature using time-resolved THz spectroscopy

Measurement of Thermal Field Temperature Distribution Inside Reaction Chamber for Epitaxial Growth of Silicon Carbide Layer

Thermal Transport at the AlN-SiC Interface and Grain Boundary of AlN

Characteristics of dynamic resistance in a heavily doped silicon semiconductor resistor

Determination of Doping and Temperature Dependent Elastic Constants of Degenerately Doped Silicon from MEMS Resonators

Giant piezoresistance of p-type nano-thick silicon induced by interface electron trapping instead of 2D quantum confinement

Realizing the nanoscale quantitative thermal mapping of scanning thermal microscopy by resilient tip-surface contact resistance models.

Thermal transport mechanism of AlN/SiG/3C-SiC typical heterostructures

Temperature resistance coefficient of doped with rare earth elements nanostructured silicon films

On the extraction of resistivity and area of nanoscale interconnect lines by temperature-dependent resistance measurements

Analytical Multistage Thermal Resistance Model for NSFET Self-heating Effects

Nonlinear piezoresistive effect of 4H–SiC for applications of high temperature pressure sensors

Experimental Investigation of Piezoresistive Effect in P-Type 4H–sic