Abstract:With types of in-house-synthesized multi-walled carbon nanotubes (CNTs) and the nitrates of the corresponding metallic components, highly active CNT-promoted Cu–ZnO–Al2O3 catalysts, symbolized as CuiZnjAlk-x%CNTs, were prepared by the co-precipitation method. Their catalytic performance for methanol synthesis from H2/CO/CO2 was studied and compared with the corresponding CNT-free co-precipitated catalyst, CuiZnjAlk. It was shown experimentally that appropriate incorporation of a minor amount of the CNTs into the CuiZnjAlk could significantly increase the catalyst activity for methanol synthesis. Under the reaction conditions of 493 K, 5.0 MPa, H2/CO/CO2/N2 = 62/30/5/3 (v/v), GHSV = 8000 h-1, the observed CO conversion and methanol formation rate over a co-precipitated catalyst of Cu6Zn3Al1-12.5%CNTs reached 36.8% and 0.291 μmol CH3OH s-1 (m2-surf. Cu)-1, which was about 44 and 25% higher than those (25.5% and 0.233 μmol CH3OH s-1 (m2-surf. Cu)-1) over the corresponding CNT-free co-precipitated catalyst, Cu6Zn3Al1. Addition of a minor amount (10–15 wt%) of the CNTs to the Cu6Zn3Al1 catalyst was found to considerably increase specific surface area, especially Cu surface area of the catalyst. H2-TPD measurements revealed that the CNTs and the pre-reduced CNT-promoted catalyst systems could reversibly adsorb and store a considerably greater amount of hydrogen under atmospheric pressure at temperatures ranging from room temperature to ∼573 K. This unique feature would be beneficial for generating microenvironments with higher stationary-state concentration of active hydrogen adspecies on the surface of the functioning catalyst, especially at the interphasial active sites since the highly conductive CNTs might promote hydrogen spillover from the Cu sites to the Cu/Zn interphasial active sites, and thus be favorable for increasing the rate of the CO hydrogenation reactions. Alternatively, the operation temperature for methanol synthesis over the CNT-promoted catalysts can be 15–20 degrees lower than that over the corresponding CNT-free contrast system. This would contribute considerably to an increase in equilibrium CO conversion and CH3OH yield. The results of the present work indicated that the CNTs could serve as an excellent promoter.

Increase the Number of Active Sites in Cu-MOR Through NO/NH3 Pretreatment for Catalytic Oxidation of Methane to Methanol

Enhancing Methane Conversion by Modification of Zn States in Co-Reaction of MTA

Noble metal modified copper-exchanged mordenite zeolite (Cu-ex-MOR) catalysts for catalyzing the methane efficient gas-phase synthesis methanol

Cu and Zn Bimetallic Co-Modified H-MOR Catalyst for Direct Oxidation of Low-Concentration Methane to Methanol

Enhancement of Methanol Selectivity in the Products of Direct Selective Oxidation of Methane in CH4–O2–NO with Cu–ZnO/Al2O3

Effect of the Preparation Method on Cu-MOR/g-C3N4 for Direct Methanol Synthesis from Methane Oxidation by Photothermal Catalysis

Oxidation of Methane to Methanol by Water Over Cu/SSZ‐13: Impact of Cu Loading and Formation of Active Sites

Highly Active CNT-Promoted Cu–ZnO–Al2O3 Catalyst for Methanol Synthesis from H2/CO/CO2

Enhancement of methanol selectivity in the products of direct selective oxidation of methane in CH4-O2-NO with Cu-ZnO/SiO2

The optimization of methanol yield in direct selective oxidation of methane with O2 and NO in the presence of Cu-ZnO/Al2O3

Critical Role of Al Pair Sites in Methane Oxidation to Methanol on Cu-Exchanged Mordenite Zeolites

Confined Cu-OH single sites in SSZ-13 zeolite for the direct oxidation of methane to methanol

Activity of Cu-Al-Oxo Extra-Framework Clusters for Selective Methane Oxidation on Cu-Exchanged Zeolites

Speciation and Reactivity Control of Cu-Oxo Clusters Via Extraframework Al in Mordenite for Methane Oxidation.

Direct oxidation of methane to oxygenates on supported single Cu atom catalyst

The exposure assessment for veterinary medicinal products.

The Enhancement Of Selectivity Of Methanol In The Presence Of Cuo/Zno/Al2o3 In The Gas Phase Partial Oxidation Of Methane

Enhancing Methane Aromatization Performance by Reducing the Particle Size of Molybdenum Oxide

Coupling of Dielectric Barrier Discharge and Cu–S-1 Catalyst for Direct Oxidation of Methane to Methanol

Effective reduction of nitric oxide over a core–shell Cu-SAPO-34@Fe-MOR zeolite catalyst

Theoretical Insights into the Selective Oxidation of Methane to Methanol in Copper-Exchanged Mordenite