Abstract:Excess sludge contains a large amount of protein and can be recycled to prepare industrial foaming agents, foliar fertilizers and other high value-added products. The optimization and effects of sludge protein extraction using the common processes of alkaline thermal hydrolysis (ATH) and enzymatic hydrolysis (EH) have been widely studied. This study focused on the protein extraction mechanisms of ATH and EH by comparing the ratio of intracellular to extracellular proteins extracted and the transformation of protein during the hydrolysis process. The extracellular protein content was 82.6 ± 5.07 mg/g VSS, and the content of intracellular protein extracted using ATH and EH was 376.9 mg/g VSS and 127.9 mg/g VSS, respectively. The ratio of intracellular to extracellular proteins extracted by ATH and EH was 4.5 and 1.5, respectively, indicating that ATH had a much better wall-breaking effect that allowed it to extract abundant intracellular proteins. The protein content obtained from ATH continuously increased over time, and approximately 38 % of proteins were further hydrolyzed to polypeptides. In contrast, the relatively low protein content extracted by EH possibly limited subsequent polypeptide hydrolysis, but subsequent hydrolysis to amino acids was not noticeably affected and was linearly correlated with the amount of protein extracted. An analysis of the recycling convenience and value of extracted proteins showed that the sludge dewatering performance increased by 86.7 % and 45.5 % after ATH and EH treatment, respectively, which was conducive to the subsequent separation of the protein solution. The protein extracted by ATH, with a large amount of peptides, would be beneficial to prepare industrial foaming agents, while the protein extracted by EH was rich in free amino acids and could be used to prepare foliar fertilizer.

Recovery of Proteins from Wastewater Generated by the Extraction of Oil Bodies Using Ultrasound-Assisted Alkali Method and Their Structural and Functional Characterization

Effects of ultrasound pretreatment on the enzymatic hydrolysis of soy protein isolates and on the emulsifying properties of hydrolysates

Protein extraction and sludge dewatering performance of ultrasound-assisted enzymatic hydrolysis of excess sludge

Intracellular and extracellular sources, transformation process and resource recovery value of proteins extracted from wastewater treatment sludge via alkaline thermal hydrolysis and enzymatic hydrolysis.

Primary isolation of spotted fever group rickettsiae from Amblyomma cooperi collected from Hydrochaeris hydrochaeris in Brazil.

Structural and Functional Changes in Ultrasonicated Oyster Protein Isolates

Effect of Ultrasonic Pulses on the Functional Properties of Stickwater

Preparation of Heat-Sensitivity Proteins from Walnut Meal by Sweep Frequency Ultrasound-Assisted Alkali Extraction

Relationship between protein native conformation and ultrasound efficiency: For improving the physicochemical stability of water–in–oil emulsions

Effect of ultrasound on oil recovery from crude oil containing sludge

Optimization of ultrasound assisted extraction of abalone viscera protein and its effect on the iron-chelating activity

Effects of ultrasound-assisted basic electrolyzed water (BEW) extraction on structural and functional properties of Antarctic krill (Euphausia superba) proteins

Effect of ultrasound on the characterization and peptidomics of foxtail millet bran protein hydrolysates

Protein extraction from excess sludge by alkali-thermal hydrolysis

Fate of proteins of waste activated sludge during thermal alkali pretreatment in terms of sludge protein recovery

A Phase II Study of Lapatinib in Recurrent/Metastatic Squamous Cell Carcinoma of the Head and Neck

Protein recovery as a resource from waste specifically via membrane technology—from waste to wonder

The Effect of Ultrasound on the Extraction and Functionality of Proteins from Duckweed (Lemna minor)

Protein Extraction from Spirulina platensis by Using Ultrasound Assisted Extraction: Effect of Solvent Types and Extraction Time

Recovery of soy whey protein from soy whey wastewater at various cavitation jet pretreatment time and their structural and emulsifying properties

Recoverability of protease released from disrupted excess sludge and its potential application to enhanced hydrolysis of proteins in wastewater