Abstract:This article presents a 140-GHz 2-D scalable wafer-scale transmit-receive (TRX) phased array based on radio frequency (RF) beamforming with 4-bit for both phase and gain controls. The chip is composed of $8\times8$ RF channels each having transmit and receive circuits, in addition to a TRX single-pole double-throw (SPDT) switch. One of the elements is replaced with an up/down-converter (UDC) channel composed of mixers, a $\times$ 6 LO multiplier chain, and intermediate frequency (IF) amplifiers at 9–14 GHz. The on-chip UDC channel is the interface between the IF signals on a printed circuit board (PCB) and the TX/RX RF distribution networks (DNs) on a chip. The 140-GHz DN is composed of coplanar waveguide (CPW) lines, Wilkinson dividers/combiners, and line amplifiers (LAs) to provide signal amplification. The chip occupies an area of 9.84 $\times$ 8.27 $\text{mm}^2$ and is designed and fabricated in GlobalFoundries, Malta, NY, USA, CMOS 45RFSOI technology. The chip is flipped on a low-cost organic RF PCB containing $8\times8$ patch antenna array placed at 1. $07\times1$ .22 $\text{mm}^2$ grid (0.5 $\lambda$ $\times$ 0.57 $\lambda$ at 140 GHz). The array electronically scans up to $\pm$ 60 $^{\circ}$ in the $H$ -plane and $\pm$ 38 $^{\circ}$ in the $E$ -plane for both TX and RX operations. Over-the-air (OTA) measured performance of the array demonstrates TX peak effective isotropic radiated power (EIRP) of 34-37.5 dBm at 137.5-145 GHz and RX input 1-dB compression point (P1dB) of $-$ 12 to $-$ 9 dBm at 134–143 GHz. Communication link measured for both TX and RX operations supports modulated 16-/64-quadrature amplitude modulation (QAM) signals with up to 24 Gb/s data rates with an rms EVM less than 7%/6%. In addition, a TRX phased array wireless links at 1.45 m and 5.2 meters are demonstrated with data rates up to 20 and 16 Gb/s using 16-QAM modulated signal and an rms EVM less than 9% for the 1.45 m link. To the best of the authors’ knowledge, this article presents the highest reported EIRP of 37.5 dBm for wafer-scale arrays in silicon technologies.

A Packaged 90-to-96GHz 16-Element Phased Array with 18.8/15.8dBm Psat/OP1dB, 14.8% TX PAE in 65nm CMOS Process and +51dBm Array EIRP

A 4-Element 7.5-9 GHz Phased Array Receiver with 8 Simultaneously Reconfigurable Beams in 65 Nm CMOS Technology

A Four-Element 7.5–9-Ghz Phased-Array Receiver with 1–8 Simultaneously Reconfigurable Beams in 65-Nm CMOS

A Ka-band 8-Element 4-Beam Transmitter Front End with Hybrid VGA and Symmetrical Transformer-based Doherty PA

A C-Band Compact High-Linearity Multibeam Phased-Array Receiver With Merged Gain-Programmable Phase Shifter Technique

A Compact Ka-Band Eight-Element Four-Beam Receiver for Low-Earth-Orbit Satellite Communications in 65-Nm CMOS

A $C$ -Band Slat-Type Phased-Array Receiver with Co-Aperture Concurrent Eight Beams

A Ka-Band 64-Element Four-Beam Phased Array Receiver with Inter-Beam Interference Cancellation

A K-Band 4-Element 8-Beam Phased-Array Receiver with Hybrid Vector Interpolation and Impedance-Adapted Multibeam Combining Techniques for Satellite Communications

Robustness‐oriented P‐band Phased Array Radar Front‐end with High Phase and Gain Resolution in 0.18 BiCMOS

An 800-Ps Origami True-Time-Delay-Based CMOS Receiver Front End for 6.5–9-Ghz Phased Arrays

A 33.5–37.5-Ghz Four-Element Phased-Array Transceiver Front-End with Hybrid Architecture Phase Shifters and Gain Controllers

A Fully Integrated 27.5-30.5 GHz 8-Element Phased-Array Transmit Front-end Module in 65 nm CMOS

A Fully Integrated X-Band Phased-Array Transceiver in 0.13-Μm CMOS Technology

A 33.5-37.5 GHz 4-Element Phased-Array Transceiver Front-End with High-Accuracy Low-Variation 6-bit Resolution 360° Phase Shift and 0~31.5 dB Gain Control in 65 nm CMOS

A 24–30-GHz 256-Element Dual-Polarized 5G Phased Array Using Fast On-Chip Beam Calculators and Magnetoelectric Dipole Antennas

W-band CMOS beamforming ICs and integrated phased-array antennas with 20+ Gb/s data rates

A 24-28 GHz Power and Area Efficient 4-Element Phased-Array Transceiver Front-End with 21.1%/16.6%transmitter Peak/OP1dB PAE Supporting 2.4 Gb/s in 256-QAM for 5-G Communications

140-GHz 2-D Scalable On-Grid 8$\times$8-Element Transmit–Receive Phased Arrays With Up/Down Converters Demonstrating a 5.2-m Link at 16 Gbps

64-Element 16–52-GHz Transmit and Receive Phased Arrays for Multiband 5G-NR FR2 Operation