Abstract:This study explores the recycling challenges of industrial sludge, owing to its non-recyclable properties and associated environmental problems. To promote sustainable energy utilization, a novel approach combining hydrothermal carbonization and co-gasification was employed to facilitate the conversion from waste to energy. The industrial sludge was pretreated in the batch-type hydrothermal treatment unit at 180-220 °C, followed by co-gasification. The experimental results indicate that pretreating the sludge at the hydrothermal temperature of 200 °C maximized its thermal decomposition, leading to a rougher structure with obvious cracks, eventually transforming into numerous fragmented small particles. At 1100 °C with a blending mass ratio of 1:1, the sludge hydrochar at 200 °C significantly enhanced the reactivity of coal char, exhibiting the gasification reactivity index R0.9 of 1.57 times higher than that of untreated char. Using the in-situ technique with the heating stage microscope, it was first observed that the addition of pretreated sludge coal chars underwent gasification in the shrinking core mode, displaying a significant ash melt flow phenomenon. Based on the in-situ X-ray diffraction, it was discovered that more amorphous structures were formed by the reaction of Fe with other minerals in the sludge-coal blended char after hydrothermal carbonization at 200 °C. With pretreatment at the hydrothermal temperature of 200 °C, the sludge can increase the specific surface area of the blended char and facilitate the cracking of carbon crystals during co-gasification. Its specific surface area and the Raman spectroscopic ratio ID1/IG were 1.76 and 1.17 times that of coal char, respectively. Collectively, this study highlights the potential for energy recovery from industrial sludge, contributing to sustainable waste management in the chemical industry.

Synergistic Effect of Physico-Chemical Properties and Reaction Temperature on the Gasification of Coal-Waste Activated Carbon-Slurry Coke for H2 Production

Research on Alkali-catalysed CO2-Gasification of Coal Black Liquor Slurry Char and Coal Water Slurry Char

Analysis on low-temperature polyethylene pyrolysis and gasification in different atmospheres

Sludge Acts As a Catalyst for Coal During the Co-Combustion Process Investigated by Thermogravimetric Analysis

Synergistic Effects of Mixing Waste Activated Carbon and Coal in Co-Slurrying and CO2 Co-Gasification

Synergistic Effect Between CO2 and H2O on Reactivity During Coal Chars Gasification

Sewage sludge steam gasification over bimetallic mesoporous Al-MCM48 catalysts for efficient hydrogen generation

Study on CO<sub>2</sub> gasification properties of coal gasification wastewater slurry

Prediction of the Ash Melting Behavior and Mineral Phase Transformation During the Co-Gasification of Waste Activated Carbon and Coal Water Slurry

Low-temperature Alkaline Pyrolysis of Sewage Sludge for Enhanced H2 Production with In-Situ Carbon Capture

Elevating clean energy through sludge: A comprehensive study of hydrothermal carbonization and co-gasification technologies

Facilitation of coke gasification by coking wastewater and its degradation properties in thermochemical reactions

STUDY ON CO-GASIFICATION OF SLUDGE AND COAL IN SUPERCRITICAL WATER

Co-pyrolysis of Coal-Derived Sludge and Low-Rank Coal: Thermal Behaviour and Char Yield Prediction

Effect of temperature and gasification gas from char on the reactions of volatiles generated from rapid pyrolysis of a low rank coal

Influence of Reactant Atmospheres and Temperature on Mechanism of Gasification of Coal Char Derived from Lignite

Effects Of Carbonization On The Co-Activation Of Sludge And Biomass To Produce Activated Coke

Co-gasification characteristics of Ca-rich sludge and Fe-rich sludge under CO2 atmosphere, and potential utilization of gasification residues as renewable catalyst in biomass pyrolysis

Co-Gasification Synergistic Characteristics of Sewage Sludge and High-Sodium Coal

Study on the effect of cyclic catalytic pyrolysis on sludge pyrolysis products

Investigation of the Characteristics of Catalysis Synergy During Co-Combustion for Coal Gasification Fine Slag with Bituminous Coal and Bamboo Residue