Abstract:The depletion of ore deposits, the increasing demand for raw materials, the need to process low-grade, complex and finely disseminated ores, and the reprocessing of tailings are challenges especially for froth flotation separation technologies. Even though they are capable of handling relatively fine grain sizes, the flotation separation of very fine and ultrafine particles faces many problems still. Further, the flotation of low-contrast semi-soluble salt-type minerals with very similar surface properties, many complex interactions between minerals, reagents and dissolved species often result in poor selectivity. This study investigates the flotation beneficiation of ultrafine magnesite rich in dolomite from desliming, currently reported to the tailings. The paper especially focuses on the impact of the depressant sodium hexametaphosphate (SHMP) on the following: (i) the froth properties using dynamic froth analysis (DFA), (ii) the separation between magnesite and dolomite/calcite, and (iii) its effect on the entrainment. As a depressant/dispersant, SHMP has a beneficial impact on the flotation separation between magnesite and dolomite. However, there is a trade-off between grade and recovery, and as well as the dewatering process which needs to be considered. When the SHMP increases from 200 g/t to 700 g/t, the magnesite grade increases from 67% to 77%, while recovery decreases massively, from 80% to 40%. The open circuit with four cleaning stages obtained a concentrate assaying 77.5% magnesite at a recovery of 45.5%. The dolomite content in the concentrate is about 20%, where 80% of dolomite was removed and importantly 98% of the quartz was removed, with only 0.3% of the quartz in the final concentrate. Furthermore, the application of 1-hydroxyethylene-1,1-diphosphonic acid (HEDP) as a more environmentally friendly and low-cost alternative to SHMP is presented and discussed. Using only 350 g/t of HEDP can achieve a similar grade (76.3%), like 700 g/t of SHMP (76.9%), while obtaining a 17% higher magnesite recovery as compared to 700 g/t of SHMP. Interestingly, the proportion of hydrophilic quartz minerals ending up in the concentrate is lower for HEDP, with only 1.9% quartz at a recovery of 21.5% compared to the 2.7% of quartz at a recovery of 24.9% when using SHMP. The paper contributes in general to understanding the complexity of the depressant responses in froth flotation.

Selective Flotation Separation of Smithsonite from Dolomite by Using Sodium Hexametaphosphate As a Depressant

Effect of Depressants in the Selective Flotation of Smithsonite and Calcite Using Cationic Collector

Study on the Reverse Flotation Separation of Smithsonite from Dolomite Using the Saponified 2-(4,4-Dimethylpentan-2-yl)-5,7,7-trimethyloctanoic Acid as a Collector

Depression of the Selective Separation of Rutile from Almandine by Sodium Hexametaphosphate

Experimental and simulation study on the flotation separation of smithsonite from dolomite using phosphoryl carboxyl copolymer as a novel depressant

Impact of Sodium Hexametaphosphate on the Flotation of Ultrafine Magnesite from Dolomite-Rich Desliming Tailings

Effect of Depressants in the Selective Flotation of Smithsonite and Calcite Using Potassium Lauryl Phosphate As Collector

Selective Flotation of Smithsonite from Dolomite by Using Novel Mixed Collector System

Selective Flotation Separation of Scheelite from Calcite Using Hexamethylenediamine Tetramethylene Phosphonic Acid As a Novel Depressant

Use of Sodium Hexametaphosphate and Citric Acid Mixture As Depressant in the Flotation Separation of Scheelite from Calcite

Mechanistic Study on the Depression of Calcite by Sodium Hexametaphosphate in Sodium Oleate System

Adsorption of a Novel Reagent Scheme on Scheelite and Calcite Causing an Effective Flotation Separation

The Enhanced Flotation Separation of Magnesite and Dolomite by Introducing Chelating Reagent EDTA

Flotation Separation of Smithsonite from Quartz Using Calcium Lignosulphonate As a Depressant and Sodium Oleate As a Collector

Selective separation of smithsonite from quartz by using sodium polyaspartate as a depressant

Hydrolytic polymaleic anhydride as a depressant for flotation separation of fine smithsonite from calcite: An experimental and MD study

Flotation separation of smithsonite and calcite in sodium oleate system using soluble starch as depressant

Study on Flotation Separation of Smithsonite and Quartzin Zn2+ System

Effect of Sodium Hexametaphosphate on Flotation of Quartz and Hematite with Starch/Etheramine in the Presence of Ca and Mg Ions

Influence of SHMP Concentration on Rutile Flotation in BHA System: Guiding the Separation of Rutile and Hornblende

Flotation Separation of Smithsonite from Calcite Using a New Depressant Fenugreek Gum