Abstract:Although various Marangoni instability patterns have been observed in evaporating sessile droplets, most are limited to a small contact angle. As a result, the droplets resemble a flat liquid layer, where the vertical temperature gradient dominates, and the hydrothermal waves (HTWs) predominantly driven by the tangential temperature gradient do not occur. In this paper, we focus on the possibility of HTWs in droplets with moderate contact angles using numerical simulation. For this purpose, a three-dimensional numerical model is proposed, in which the deformation of the droplet surface induced by evaporation can be directly calculated from the local evaporation flux. We predict fan-like HTWs with three blades in the droplet. The waves are located at the center region of the droplet and are uniformly distributed throughout the circumference; they simultaneously propagate along the anticlockwise and radial directions. With evaporation, the blades become shorter, whereas the fan-like shape and wave number remain without significant variation. The behavior of the fluid flow inside the droplet and its oscillatory characteristics were analyzed carefully. The numerical results were verified by experiments, and confirm that HTWs would only occur under moderate contact angles. Additionally, a higher substrate temperature or a larger initial radius would promote the appearance of the irregular fan-like HTWs with two blades, whereas a sufficient small initial radius will inhibit the appearance of HTWs. The effects of the substrate temperature, the initial radius and the contact angle on the critical radius and the corresponding critical normal Marangoni number (Ma(v,)(c)) for the disappearance of the HTWs were also studied. (C) 2021 Elsevier Ltd. All rights reserved.

Marangoni Convection Instabilities in an Evaporating Droplet on a Non-Isothermal Substrate

Marangoni Convection Instability Inside an Evaporating Droplet on an Inclined Substrate

Marangoni Convection Instability in an Evaporating Droplet Deposited on Volatile Liquid Layer

Influence of substrate temperature on Marangoni convection instabilities in a sessile droplet evaporating at constant contact line mode

Transition of Marangoni convection instability patterns during evaporation of sessile droplet at constant contact line mode

Bénard-Marangoni Instability in Sessile Droplet Evaporating at Constant Contact Angle Mode on Heated Substrate

Marangoni convection instability in a sessile droplet with low volatility on heated substrate

Longitudinal roll patterns of Marangoni instability in an easily volatile sessile droplet evaporating at constant contact angle mode

Experimental Investigation on Marangoni Convection Instability Induced by Evaporation in a Sessile Droplet of Silicone Oil on a Heated Substrate

Marangoni instability induced by evaporation in well-defined non-spherical sessile droplet

Modeling unsteady Bénard-Marangoni instabilities in drying volatile droplets on a heated substrate

Instability Patterns of Marangoni Flow in Evaporating Droplets on Lyophobic Surface

Three-Dimensional Numerical Simulation on Marangoni Convection in a Sessile Water Droplet Evaporating in Its Vapor at Low Pressure

Numerical investigation on flow instability of sessile ethanol droplets evaporating in its pure vapor at low pressure

Marangoni Convection in Evaporating Sessile Droplet With Constant Angle by Numerical Simulation

Experimental Investigation on Evaporation Dynamics of Sessile Ethanol Droplets on a Heated Substrate

Influence of thermal properties on hydrothermal waves in evaporating sessile droplets

Marangoni Convection in Evaporating Organic Liquid Droplets on A Nonwetting Substrate

Experimental and numerical study of droplet formation with Marangoni instability

Marangoni convection in an evaporating water droplet

Hydrothermal Waves in Sessile Droplets Evaporating at a Constant Contact Angle Mode