Abstract:Kraft lignin grafted with hydrophilic polymers has been prepared using reversible addition-fragmentation chain-transfer (RAFT) polymerization and investigated for use as a surfactant. In this preliminary study, polyacrylamide and poly(acrylic acid) were grafted from a lignin RAFT macroinitiator at average initiator site densities estimated to be 2 per particle and 17 per particle. The target degrees of polymerization were 50 and 100, but analysis of cleaved polyacrylamide was consistent with a higher average molecular weight, suggesting not all sites were able to participate in the polymerization. All materials were readily soluble in water, and dynamic light scattering data indicate polymer-grafted lignin coexisted in isolated and aggregated forms in aqueous media. The characteristic size was 15-20 nm at low concentrations, and aggregation appeared to be a stronger function of degree of polymerization than graft density. These species were surface active, reducing the surface tension to as low as 60 dyn/cm at 1 mg/mL, and a greater decrease was observed than for polymer-grafted silica nanoparticles, suggesting that the lignin core was also surface active. While these lignin surfactants were soluble in water, they were not soluble in hexanes. Thus, it was unexpected that water-in-oil emulsions formed in all surfactant compositions and solvent ratios tested, with average droplet sizes of 10-20 μm. However, although polymer-grafted lignin has structural features similar to nanoparticles used in Pickering emulsions, its interfacial behavior was qualitatively different. While at air-water interfaces, the hydrophilic grafts promote effective reductions in surface tension, we hypothesize that the low grafting density in these lignin surfactants favors partitioning into the hexanes side of the oil-water interface because collapsed conformations of the polymer grafts improve interfacial coverage and reduce water-hexanes interactions. We propose that polymer-grafted lignin surfactants can be considered as random patchy nanoparticles with mixed hydrophilic and hydrophobic domains that result in unexpected interfacial behaviors. Further studies are necessary to clarify the molecular basis of these phenomena, but grafting of hydrophilic polymers from kraft lignin via radical polymerization could expand the use of this important biopolymer in a broad range of surfactant applications.

Interfacial Adsorption of Oil-Soluble Kraft Lignin and Stabilization of Water-in-Oil Emulsions

Emulsion Stabilization by Cationic Lignin Surfactants Derived from Bioethanol Production and Kraft Pulping Processes

Controlling stabilization of oil‐in‐water emulsions with lignins through fractionation, functionalization, and formulation

Pickering Emulsion Via Interfacial Assembly of Lignin Particles and Cationic Surfactant: Formation of Robust Anchoring Layer

Lignins interfacial behavior tailored by formulation parameters

Adsorption of Dietary Oils Onto Lignin for Promising Pharmaceutical and Nutritional Applications

Multiphasic lignocellulose-based suspension for oil-water interfacial stabilization: Synergistic adsorption and phase behavior

Enzymatic Transesterification of Kraft Lignin with Long Acyl Chains in Ionic Liquids

Synthesis of Branched Surfactant Via Ethoxylation of Oleic Acid Derivative and Its Surface Properties

Preparation and Surface Properties Investigation of Lignin-Phonls Non-Ionic Surfactant

Synthesis of Surfactants from Alkali Lignin for Enhanced Oil Recovery

Studies on A Novel Modified Lignin Surfactant

Synthesis, characterization and performance of lignin carboxyl betaine zwitterionic surfactants for application in enhanced oil recovery

Polymer-grafted lignin surfactants prepared via reversible addition-fragmentation chain-transfer polymerization

Research Interfacial Properties of the Novel Lignosulfonates

Surface and interface characteristics of hydrophobic lignin derivatives in solvents and films

Oxidation of Organosolv Lignin in a Novel Surfactant-Free Microemulsion Reactor.

Synthesis of a lignin-based alcohol ether carboxylate surfactant and its application as cotton fiber detergent

Systematic Investigation of the Physicochemical Properties of Eco-Friendly Biobased Anionic-Nonionic Surfactants for Enhanced Oil Recovery

Study on Synthesis and Performance of Lignin Polyether Sulfonate Surfactants for Enhanced Oil Recovery

Aqueous Dispersions of Esterified Lignin Particles for Hydrophobic Coatings