Abstract:A parallel direct-forcing fictitious domain method is employed to perform fully resolved numerical simulations of turbulent channel flow laden with finite-size particles. The effects of the particle-fluid density ratio on the turbulence modulation in the channel flow are investigated at the friction Reynolds number of 180, the particle volume fraction of 0.84%, and the particle-fluid density ratio ranging from 1 to 104.2. The results show that the variation of the flow drag with the particle-fluid density ratio is not monotonic, with a larger flow drag for the density ratio of 10.42, compared to those of unity and 104.2. A significant drag reduction by the particles is observed for large particle-fluid density ratios during the transient stage, but not at the statistically stationary stage. The intensity of particle velocity fluctuations generally decreases with increasing particle inertia, except that the particle streamwise root-mean-square velocity and streamwise-transverse velocity correlation in the near-wall region are largest at the density ratio of the order of 10. The averaged momentum equations are derived with the spatial averaging theorem and are used to analyze the mechanisms for the effects of the particles on the flow drag. The results indicate that the drag-reduction effect due to the decrease in the fluid Reynolds shear stress is counteracted by the drag-enhancement effect due to the increase in the total particle stress or the interphase drag force for the large particle-inertia case. The sum of the total Reynolds stress and particle inner stress contributions to the flow drag is largest at the density ratio of the order of 10, which is the reason for the largest flow drag at this density ratio. The interphase drag force obtained from the averaged momentum equation (the balance theory) is significantly smaller than (but agrees qualitatively with) that from the empirical drag formula based on the phase-averaged slip velocity for large density ratios. For the neutrally buoyant case, the balance theory predicts a positive interphase force on the particles arising from the negative gradient of the particle inner stress, which cannot be predicted by the drag formula based on the phase-averaged slip velocity. In addition, our results show that both particle collision and particle-turbulence interaction play roles in the formation of the inhomogeneous distribution of the particles at the density ratio of the order of 10.

General Drag Correlations for Particle-Fluid System

Models of Interphase Drag Force from Direct Numerical Simulations of Upward Turbulent Particle-Laden Channel Flows

Drag Model from Interface-Resolved Simulations of Particle Sedimentation in a Periodic Domain and Vertical Turbulent Channel Flows

Homogeneous drag models in gas–solid fluidization: Big data analytics and conventional correlation

General Drag Coefficient for Flow over Spherical Particles

A General Solution of the Drag Force in Packed Beds of Multi-Sized Particles under Creeping Fluid Flow Conditions

A Linkage Between Particle- and Cell-scale Drag Correlations for Packed Beds of Multi-sized Particles

Structure-dependent Drag in Gas–solid Flows Studied with Direct Numerical Simulation

Effects of Particle-Fluid Density Ratio on the Interactions Between the Turbulent Channel Flow and Finite-Size Particles.

A General Drag Coefficient for Flow over a Sphere

Drag Force Model Corrections Based on Nonuniform Particle Distributions in Multi-Particle Systems

General Formulation of Drag Force on Assemblage of Spherical Particles in Fluids: A Critical Review and A New Empirical Formula

A Critical Comparison of Two-Fluid Model, Discrete Particle Method and Direct Numerical Simulation for Modeling Dense Gas-Solid Flow of Rough Spheres

Analysis and Simulation of Fluid-Particles Interaction with Particle Flow Code

Drag Force in Dense Gas-Particle Two-Phase Flow

Particle-resolved simulation of freely evolving particle suspensions: Flow physics and modeling

Drag Correlations for Flow Past Monodisperse Arrays of Spheres and Porous Spheres Based on Symbolic Regression: Effects of Permeability

Improved Drag Force Model and Its Application in Simulating Nanofluid Flow

Drag of a Single Particle Within a Multi-Particle System in Supercritical Water

Numerical Investigation of the Drag Force of Interactive Particles in Supercritical Water

Numerical study of the interaction between cylindrical particles and shear-thinning fluids in a linear shear flow