Abstract:This paper firstly presents an extended sliding mode observer (ESMO) for the electro-hydraulic servo systems (EHSSs) to deal with nonlinear factors like the external disturbance, parameter uncertainties as well as unmodeled characteristics in the EHSS. The model for the EHSS is established by taking these nonlinear factors into consideration and then the statespace representation is obtained. According to the state space, the ESMO for the EHSS is presented, the equivalence principle is properly utilized to simplify the ESMO and some saturation functions are employed to eliminate high frequency interferences caused by the chattering phenomenon. Based on estimated values from the ESMO, a robust adaptive backstepping controller (RABC) is presented in detail with taking some parameter uncertainties into consideration to further improve the tracking performance. The proposed controller has the following advantages: (1) utilizing the ESMO to cope with these nonlinear factors; (2) parameter online adaptive laws are employed in the RABC design to further improve the tracking performance. In order to verify the performance of the proposed controller, an experiment bench was established. Two sine waves reference signal (one amplitude 0.01 m, 1 Hz; the other 0.015 m, 2 Hz) are employed to verify the performance of the controller. Comparative experimental results show that: (1) the tracking performance of the proposed controller is better than that of a DOs based BC, a BC and a PI controller; (2) estimation values from the ESMO contains fewer noise than two conventional disturbance observers (DOs), which will decrease the control input ripples.

Neural Direct Adaptive Active Disturbance Rejection Controller for Electro-hydraulic Servo System

Backstepping Robust Adaptive Control for an Electro-Hydraulic Servo System

Nonlinear Robust Adaptive Control of Electro-hydraulic System

Nonlinear adaptive position tracking of an electro-hydraulic actuator

Nonlinear Motion Control of a Hydraulic Press Based on an Extended Disturbance Observer

Adaptive time-varying sliding mode control for hydraulic servo system

RISE-based adaptive control of electro-hydraulic servo system with uncertain compensation

Adaptive LADRC-Based Disturbance Rejection Method for Electromechanical Servo System

Model reference adaptive control of electro-hydraulic servo system based on RBF neural network and nonlinear disturbance observer

Disturbance Observer-Based Sliding Mode Controller for Underwater Electro-Hydrostatic Actuator Affected by Seawater Pressure

Linear active disturbance rejection control for the electro-hydraulic position servo system

Extended sliding mode observer based robust adaptive backstepping controller for electro-hydraulic servo system: Theory and experiment

Active Disturbance Rejection Control for Hydraulic Width Control System for Rough Mill

Design of a Electro-Hydrostatic Actuator Controller Based on Disturbance Observer.

Adaptive Robust Dead-Zone Compensation Control of Electro-Hydraulic Servo Systems with Load Disturbance Rejection.

An Event-Triggered Based Robust Control for Electro-Hydraulic Servo Machines with Active Disturbances Rejection

Model Reduction and Neural Network Adaptive Control of Nonlinear Hydraulic System Based on Extended State Observer

Neural Adaptive Control of Single-Rod Electrohydraulic System with Lumped Uncertainty

Adaptive Robust Dynamic Surface Control of Electro-hydraulic System with Unknown Nonlinear Disturbance

Model-Assisted Active Disturbance Rejection Control for Electro-Hydraulic Position Servo System With Mismatched Disturbances and Measurement Noise

Electro-Hydrostatic Actuator Active Disturbance Rejection Control Based on Cascade Expansion Observers