Abstract:Currently, removing arsenic (As) from ZnSO 4 solution using lime presents several drawbacks, including high wet precipitate content, long reaction time, and the introduction of new impurities. In this study, we propose a novel ultrasonic (US) ozone one-pot method for effectively removing As from a high-arsenic ZnSO 4 solution. In this method, as in ZnSO4 solution was removed by ultrasound enhanced ozone oxidation combined with zinc roasting dust (ZRD). No secondary pollution will occur with the addition of ZRD and ozone, as neither introduces new impurities. The experimental results show that under the conditions of initial As and Fe concentrations of 1640 mg/L and 2963 mg/L, US power of 480 W, frequency of 20 kHz, reaction temperature of 60 °C, reaction time of 1 h, ZRD dose of 12 g/L and gas flow rate of 900 mL/min, the removal rate of As can reach 99.4%. The introduction of US can further enhance the oxidation effect of ozone on As(III) and Fe 2+ by increasing the solubility of ozone and promoting the production of OH radicals. Additionally, US cavitation and mechanical action increase the probability of contact between various reactants in the solution, facilitating the occurrence of reactions. US also reduces the aggregation of arsenic-containing precipitates and the encapsulation of ZRD by arsenic containing precipitates, thereby decreasing the amount of arsenic-containing precipitates. In comparison to the traditional lime method, this approach results in a significant reduction in the amount of arsenic-containing precipitate by 54.5% and a 60% decrease in the total reaction time. The As removal mechanism of our method encompasses ZRD neutralization, US-enhanced ozone mass transfer and decomposition, oxidation of As(III) and Fe 2+ , and adsorption and coprecipitation. Consequently, the proposed method provides a cost-effective, fast, safe and environmentally friendly alternative for treating arsenic-contaminated ZnSO 4 solutions.

Effect of pH on oxygen-induced abio-oxidation and removal of As from As-rich acid mine drainage in the co-existence of Zn(II)

Effect of co-existent Al(III) in As-rich Acid Mine Drainage (AMD) on As removal during Fe(II) and As(III) abiotic oxidation process

Rapid Abiotic As Removal from As-rich Acid Mine Drainage: Effect of Ph, Fe/As Molar Ratio, Oxygen, Temperature, Initial As Concentration and Neutralization Reagent

A combined abiotic oxidation-precipitation process for rapid As removal from high-As(III)-Mn(II) acid mine drainage and low As-leaching solid products

Mineral Transformation of Structural Fe(II) Hydroxides with O 2 , Cu(II), Cr(VI) and NO 2 − for Enhanced Arsenite Sequestration

Opposite effects of dissolved oxygen on the removal of As(III) and As(V) by carbonate structural Fe(II)

As(III) removal and speciation of Fe (Oxyhydr)oxides during simultaneous oxidation of As(III) and Fe(II).

Advantages of Aeration in Arsenic Removal and Arsenite Oxidation by Structural Fe(II) Hydroxides in Aqueous Solution

Pivotal effects of external Fe2+ on remediation of arsenite by zero-valent iron/persulfate: Efficiencies and mechanism

Synergistic Oxidation of Dissolved As(III) and Arsenopyrite in the Presence of Oxygen: Formation and Function of Reactive Oxygen Species

Arsenic Oxidation and Immobilization in Acid Mine Drainage in Karst Areas.

Effective photocatalytic removal of As(III) by ZnFe<sub>2</sub>O<sub>4</sub>/Ag/AgCl coupled peroxymonosulfate: Z-Scheme charge transfer and dual active sites

Efficient photo-oxidation remediation strategy toward arsenite-contaminated water and soil with zinc-iron layered double hydroxide as amendment

Effects of pH on coprecipitation of As(III) with biogenic synthesized schwertmannite and jarosite

Fe/S oxidation-coupled arsenic speciation transformation mediated by AMD enrichment culture under different pH conditions

Effective removal of As from a high arsenic-bearing ZnSO 4 solution by ultrasonic enhanced ozonation in a one-pot method

A novel application of H2O2–Fe(II) process for arsenate removal from synthetic acid mine drainage (AMD) water

In-situ Utilization of As(III) Enhances Selective Recovery of Heavy Metals from Acid Mine Drainage by Hydroxyl-Enriched Fe-Mn Binary Oxide

Pivotal effects of external Fe<SUP>2+</SUP> on remediation of arsenite by zero-valent iron/persulfate: Efficiencies and mechanism

Efficient oxidation of arsenic in aqueous solution using zero valent iron- activated persulfate process

Facile Synthesis of Manganese Dioxide Nanoparticles for Efficient Removal of Aqueous As(III)