Abstract:This study introduces a cost-effective, mild thermal abiotic humification method for producing highly humified artificial humic acids (AHAs) from lignin-rich biogas digestate. Derived from the anaerobic digestion of cattle manure, the digestate slurry undergoes an MnO 2 -KOH-urea-enhanced humification reaction. Key process variables, such as MnO 2 dose (0–15 mg/L), KOH dose (0–1 mol/L), urea dose (0–1.2 mol/L), reaction time (30–150 min), and temperature (25–85 °C), were systematically explored to optimize AHA yield, carboxylic acid content, and lignin removal. Optimal conditions, employing 7.69 mg/L of MnO 2 , 0.57 mol/L of KOH, and 0.63 mol/L of urea at 85 °C for 106 min, resulted in an impressive AHA yield of 32.15%, featuring a significant carboxylic acid content of 3.325 mmol/g. Under these conditions, up to 65% of lignin was effectively removed, accompanied by the release of orthophosphate up to 258 mg/L. The produced AHAs exhibited reduced toxicity, as demonstrated by substantial reductions of 54.13%, 57.14%, and 42.50% in phenols, furfural, and hydroxymethylfurfural, respectively. Notably, the AHAs displayed favorable characteristics, including a lower molecular weight (760.49 g/mol), diminished aromaticity (66.25% reduction), higher humification degree (lower C/N ratio of 8.79), increased oxidation degree (higher O/C ratio of 0.6), and elevated spectral index of humification (higher E4/E6 of 4.58). Analytical techniques, such as FT-IR, XPS, and TGA-MS, revealed chemical resemblance and enhanced functionality of AHAs compared to natural counterparts. Differentiation between AHA, lignin, and humification residues was confirmed through SEM-EDX, ICP-OES, and organic/inorganic carbon analyses. The obtained AHAs exhibit promising characteristics suitable for diverse applications in sustainable agriculture and environmental management.

Production of artificial humic acid from biomass residues by a non-catalytic hydrothermal process

From biomass to humic acid: Is there an accelerated way to go?

Two-step hydrothermal conversion of biomass waste to humic acid using hydrochar as intermediate

Enhanced Production of Hydrothermal Humic Acid in a Two-Step Hydrothermal Process with Acid Hydrothermal Solution Recycling

Hydrothermal humification mechanism of typical agricultural waste biomass: A case study of corn straw

Production of artificial humic acid from corn straw acid hydrolysis residue with biogas slurry impregnation for fertilizer application

Optimization of alkaline hydrothermal treatment for humic acids production from corn straw digestate using the response surface methodology

Iron oxyhydroxide catalyzes production of artificial humic substances from waste biomass

Artificial humic acid produced from wet distillers grains in a microwave-assisted hydrothermal process: Physicochemical characteristics and stimulation to plant growth

Humic Acid from Hydrochar: Correlation Between Unsaturation and Hydrothermal Humification of Hydrochar

Review: Biotic and abiotic approaches to artificial humic acids production

A hydrothermal process to turn waste biomass into artificial fulvic and humic acids for soil remediation

Insight into the Co-Hydrothermal Humification of Corn Stalk and Sewage Sludge for Enhanced Nitrogen-Rich Humic Acid Production

Direct humification of biowaste with hydrothermal technology: A review

Acid Hydrothermal Solution Recycling Enhanced Alkaline Hydrothermal Humification of Hydrochar

Properties and photosynthetic promotion mechanisms of artificial humic acid are feedstock-dependent

Hydrothermal Humification of Lignocellulosic Components: Who is Doing What?

Production of artificial humic acid from rice straw for fertilizer production and soil improvement

Humic Substances Derived From Biomass Waste During Aerobic Composting and Hydrothermal Treatment: A Review

Hydrothermal synthesis of similar mineral-sourced humic acid from food waste and the role of protein

Oxidation-alkaline-enhanced abiotic humification valorizes lignin-rich biogas digestate into artificial humic acids