Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Numerical investigation on water evaporation characteristics at low pressures in a stainless steel funnel

A Study on Flow and Heat Transfer Characteristics for Saturated Falling-Film Evaporation of Liquid Oxygen in a Vertical Channel

Study on evaporation induced flow characteristics and interfacial phenomena of water in a sidewall-heated cylindrical pool at low pressures

Numerical study of droplet evaporation in coupled high-temperature and electrostatic fields

Numerical Investigation of Evaporation-Induced Flow Around Sessile Droplets Using a Sharp-Interface Algebraic VOF Approach

Numerical investigation on the coupling effect of sessile ethanol droplet evaporation and the induced thermal flow in its pure vapor environment at low pressure

Water film heating evaporation under low pressure

Investigation on Evaporation Characteristics of Ethanol in Annular Pool with Different Liquid Layer Depths at Low Pressures

Droplet Evaporation to Boiling in Van Der Waals Fluid

Measurement of Temperature Profile Near the Evaporating Interface in an Annular Pool with Radial Temperature Gradients at Low Pressures

Three-Dimensional Numerical Simulation on Marangoni Convection in a Sessile Water Droplet Evaporating in Its Vapor at Low Pressure

Effect of buoyancy-thermocapillary convection on evaporation process of water in cylindrical pool heated by sidewall at low pressures

Numerical Simulation of Thermocapillary Flow Induced by Non-Uniform Evaporation on the Meniscus in Capillary Tubes

Experimental and Numerical Investigations on Flash Evaporation of a Sessile Droplet under Reduced Pressure

Experimental Investigation of Evaporation Dynamic of Sessile Droplets in Pure Vapor Environment with Low Pressures

Numerical Investigation on Fluid Flow Characteristics of Thin Film Evaporation Meniscus Region in the Rectangular Groove

Boiling and evaporation model for liquid-gas flows: A sharp and conservative method based on the geometrical VOF approach

Numerical investigation on flow instability of sessile ethanol droplets evaporating in its pure vapor at low pressure

Numerical Study On Evolution Of Sessile Water Droplets During Evaporation

Internal Flow in Evaporating Droplet on Heated Solid Surface

Evaporation Kinetics of Sessile Water Droplets on a Smooth Stainless Steel Surface at Elevated Temperatures and Pressures