Abstract:In the present study, water-oil flow patterns and slug hydrodynamics were experimentally studied in square glass microchannels with various hydraulic diameters (Dh = 600 μm, 400 μm, 200 μm). The aqueous phase is the continuous phase while the organic phase is the dispersed phase. The ranges of flow rates of the continuous phase and the dispersed phase are 0–200 ml/h and 0–12 ml/h, 0–120 ml/h and 0–6 ml/h, and 0–60 ml/h and 0–2 ml/h in the microchannels with Dh = 600 μm, 400 μm and 200 μm, respectively. The results show that the hydraulic diameter has significant effects on flow patterns and three main flow patterns are observed, i.e., annular flow, slug flow and droplet flow. Generally, annular flow appeared at high flow rates of the dispersed phase and low flow rates of the continuous phase, while droplet flow appeared at low flow rates of the dispersed phase and high flow rates of the continuous phase. However, slug flow existed at comparable flow rates of the continuous and dispersed phases. A dimensionless analysis is carried out and a new dimensionless group including Weber number and Reynolds number is derived. The new defined dimensionless group performs well to develop a general flow pattern map. In addition, slug flow hydrodynamics are investigated as well in the present study, considering the slug length and slug velocity. Based on the present experimental results, a new scaling law is proposed to predict the slug length and it shows a good agreement with the experimental results. It has been widely reported that slug velocities depend linearly on the total flow rates of the two phases, which is consistent with the present study. The linear law provides a good prediction of the experimental slug velocities but different slopes are suggested in microchannels with different hydraulic diameters.

Liquid–liquid Two-Phase Flow and Size Distribution of Droplets in Milli-Channels: Effect of Gravity

Liquid-liquid Two-Phase Flow and Mass Transfer in T-shaped Micro-Channel Network

Hydrodynamics and Mass Transfer of Liquid-Liquid Two-Phase Flow in Circular Milli-Channels: Sizing-up Effect

EFFECTS OF INLET ARRANGEMENTS ON LIQUID-LIQUID FLOW PATTERNS IN CROSS-JUNCTION SQUARE MICROCHANNELS

WATER-OIL FLOW IN SQUARE MICROCHANNELS WITH A CROSSED JUNCTION

Slug Formation Analysis of Liquid–Liquid Two-Phase Flow in T-Junction Microchannels

Experimental Studies of Droplet Formation Process and Length for Liquid–Liquid Two-Phase Flows in a Microchannel

Mixing Efficiency Analysis On Droplet Formation Process In Microchannels By Numerical Methods

Synthesis of scalable microdroplets with fluid instability of shearing flow in microfluidics

Liquid–Liquid Two-Phase Flow and Size Prediction of Slug Droplets in Microchannels

Effects of Two-Phase Periodic Velocity on Droplet Coalescence Inside Microchannels

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Millisecond Mixing of Two Liquid Streams in a Mixer Model

Enhancement of Mass Transfer Performance of Liquid–liquid System by Droplet Flow in Microchannels

Gas–liquid–liquid Slug Flow and Mass Transfer in Hydrophilic and Hydrophobic Microreactors

Experimental and Numerical Study of Mixing Behavior Inside Droplets in Microchannels

Effect of Viscosity on Liquid–Liquid Slug Flow in a Step T-Junction Microchannel

Phase Distribution of Gas–Liquid Slug–Annular Flow in Horizontal Parallel Micro-Channels

Liquid–liquid Two‐phase Flow in Pore Array Microstructured Devices for Scaling‐up of Nanoparticle Preparation

Bubble/Droplet Formation and Mass Transfer During Gas-Liquid-Liquid Segmented Flow with Soluble Gas in A Microchannel

Characterization of Liquid-Liquid Two-Phase Flow Patterns and Mass Transfer Coefficients in Human-Shaped Microchannels