Abstract:Grouting is a common method to improve the mechanical properties of the fractured rock mass. Understanding the effect of grouting on the mechanical properties of fractured rock mass is considered essential for the establishment of efficient grouting designs and the development of new grouting materials. Therefore, in this research, a series of experiments are conducted to reveal the influence of grouting material on the mesostructure and macroscopic mechanical behavior of the grout-rock interface. Firstly, grouted samples with different grouting materials (ordinary Portland cement (OPC), microfine cement (MFC), and epoxy resin (EPR)) were prepared. Then, nuclear magnetic resonance (NMR) and X-ray computed tomography (CT) were carried out on the grouted rock mass to investigate the pore phase composition and mesostructure. Subsequently, correlating acoustic emission (AE) counts and shear stress-displacement curves reveal the shear failure process of the grouted rock mass. Finally, the failure mechanism of grouted rock mass was discussed in detail. The results displayed that the damage characteristic during shear failure of the grouted rock mass may be inferred from the AE counts. The shear strength of the sample grouted with OPC, MFC, and EPR is 8.3%, 41.5%, and 142.8% of that of intact rock, respectively. EPR reduces the pore content at the grout-rock interface compared with cement-based grout, especially the macropores and the micropores. Compared with the rock layer, the number of pores at the grout-rock interface of the sample grouted with OPC, MFC, and EPR is reduced by 43.3%, 57.1%, and 64.3%, respectively. The hydrophilicity of the rock leads to a discrepancy in the hydration degree of cement-based grout, which causes uneven shrinkage of the grout and produces cracks. However, as a chemical grouting material, EPR may permeate into the rock interior and modify the mesostructure of the grout-rock interface. The grout-rock bonding and mesostructure of the grout-rock interface dominate the failure mechanism, thus determining the macroscale mechanical properties of the grouted rock mass.

Adhesion Behavior and Deposition Morphology of Cement Grout Flowing Through Granular Materials

Sedimentation-affected Engineering Performances and Microstructures of a Hybrid Portland- Sulfate Aluminate Cement Grout Cast in Long Tubes

Rheology and Yield Stress Evolution of Highly Flowable Cementitious Grouting Materials: Mechanisms and Modeling

Dynamic Densification of Wet Granular Materials in Continuous Dense Flows under Gravity

Numerical Investigation of Grout Diffusion Accounting for the Dynamic Pressure Boundary Condition and Spatiotemporal Variation in Slurry Viscosity

Effects of Cementing Matrix Characteristics and Particle Size on the Adhesion Rule and Mechanical Properties of Cemented Granular Materials

Mechanics of the Penetration and Filtration of Cement-Based Grout in Porous Media: New Insights from CFD–DEM Simulations

X-ray Microtomography Study on the Cemented Structure of Cemented Granular Materials

Filtration Behaviour of Cement-Based Grout in Porous Media

Micromechanism of the Diffusion of Cement-Based Grouts in Porous Media under Two Hydraulic Operating Conditions: Constant Flow Rate and Constant Pressure

Influence of the flocculation effect on the rheological properties of cement slurry

Effect of Additives on the Rheological and Mechanical Properties of Microfine-Cement-Based Grout

Mechanism of Filtration Behaviors of Cement-Based Grout in Saturated Sand under Different Grouting Conditions

Analysis of thixotropy of cement grout based on a virtual bond model

Multiscale Poromechanics of Wet Cement Paste

Experimental-numerical investigation on grout diffusion and washout in rough rock fractures under flowing water

Experimental Study on Flow Water Diffusion of Cement-Sodium Silicate Grouting in Rough Fracture Model

Fluids flow in granular aggregate packings reconstructed by high-energy X-ray computed tomography and lattice Boltzmann method

Effect of Cohesion on Granular-Fluid Flows in Spouted Beds: PIV Measurement and DEM Simulations

Experimental investigation on the failure mechanism of grouted rock mass: Mesostructure and macroscopic mechanical behavior

A model of cement grout flow in a fracture network system