Abstract:Energy storage devices are the hub of a multi-energy complementary distributed energy system. Hydrated salts are the most suitable phase change material for energy storage devices, but subcooling is the main obstacle to their application. Nucleation requires a driving force so the use of nucleating agents alone does not reduce subcooling to a very low level. To address this issue, this paper first screened nucleating agents and then further reduced the subcooling of sodium acetate trihydrate in conjunction with stirring or direct current. The effects of rotor mass, rotational speed, direct current voltage, and electrode material on nucleation were analyzed. Finally, the stability of the composite phase change material in the presence of simultaneous stirring and energization was analyzed. The results showed that the addition of 1.5% in weight of disodium hydrogen phosphate dodecahydrate to sodium acetate trihydrate can reduce the subcooling to about 2.3°C. Continued addition of stirring or electricity can reduce the subcooling of sodium acetate trihydrate to within 0.5°C or even eliminate it. The higher the momentum of the stirring, the better the improvement in subcooling, phase separation, and thermal conductivity. The higher the direct current voltage, the better the nucleation effect, but the electrode life will be lower. The silver electrode has the best nucleation effect. No new material was produced in the solution after 100 cycles in the presence of both stirring and direct current. The melting point of the phase change material was increased by 0.2°C and the latent heat value decreased by 1.8%, still with good stability. The trace of deionized water should be added to the phase change material in subsequent studies to compensate for the consumption of water by the anodic elution.

Electrically-controlled Crystallization of Supercooled Sodium Acetate Trihydrate Solution

Experimental study on the electrically-triggered crystallization behavior of supercooled copper foam-based and expanded graphite-based sodium acetate trihydrate

Improvement of the Subcooling Problem of Sodium Acetate Trihydrate by a Combination of Stirring or Internal Electric Field and Nucleating Agent

Electrically driven nucleation for enhanced control of salt hydrate hydrogel heat release in long-term thermal storage applications

Non-Isothermal Crystallization of Aqueous Nanofluids with High Aspect-Ratio Carbon Nano-Additives for Cold Thermal Energy Storage

Preparation and Thermal Properties of Sodium Acetate Trihydrate As a Novel Phase Change Material for Energy Storage

Experimental study on supercooling performance optimization of sodium acetate trihydrate phase change energy storage materials

The Experimental Exploration of Sodium Chloride Solution on Thermal Behavior of Phase Change Materials

Preliminary Supercooling Research on Calcium Chloride Hexahydrate as Phase Change Material

High-density and Anti-Clogging Three-Phase Absorption Heat Storage with Crystallization Management

Manipulating Ice Crystallization Of 0.9 Wt.% Nacl Aqueous Solution By Alternating Current Electric Field

Optimization of supercooling, thermal conductivity, photothermal conversion, and phase change temperature of sodium acetate trihydrate for thermal energy storage applications

Development of a sodium acetate trihydrate-based phase change material for efficient solar/electric-to-thermal energy conversion

Thermal characteristics of a long-term heat storage unit with sodium acetate trihydrate

Optimization of super water-retention phase change gels for cold energy storage in cold chain transportation

Experimental Study on Phase Change Thermal Storage of Crystalline Hydrated Salt Applied in Solar Thermal Utilization

Thermal energy storage properties of carbon nanotubes/sodium acetate trihydrate/sodium monohydrogen phosphate dodecahydrate composite phase-change materials as promising heat storage materials

Experimental investigation on nucleating agent for low temperature binary eutectic salt hydrate phase change material

Undercooling-directed NaCl Crystallization: an Approach Towards Nanocavity-Linked Graphene Networks for Fast Lithium and Sodium Storage.

Nucleation in Supercooled Water Triggered by Mechanical Impact: Experimental and Theoretical Analyses

The Effects of Nucleating Agents on Phase Transition of a Salt Hydrate Phase-Change Material for Thermal Energy Storage Heat Exchangers