Effect of steam and CO2 on ethane activation over Zn-ZSM-5

Ali Mehdad,Nicholas S. Gould,Bingjun Xu,Raul F. Lobo

DOI: https://doi.org/10.1039/c7cy01850a

2018-01-01

Abstract:Hydrolysis of Zn(ii) sites in Zn-ZSM-5 suppresses ethane oligomerization and aromatization.

What problem does this paper attempt to address?

Effect of steam and CO2 on ethane activation over Zn-ZSM-5

Ali Mehdad,Nicholas S. Gould,Bingjun Xu,Raul F. Lobo

DOI: https://doi.org/10.1039/c7cy01850a

IF: 6.177

2018-01-01

Catalysis Science & Technology

Abstract:The impact of steam and CO2 on ethane activation over 5% (w/w) Zn-ZSM-5 catalysts was investigated. The main products in He, steam and CO2 were mixtures of ethene, methane, benzene and toluene. CO2 clearly increased the formation rate of ethene and CO, and steam increased the formation rate of ethene. In addition, the presence of CO2 decreased the formation rates of methane and aromatics by factors of similar to 3 and 7, respectively. Hydrogen formed from ethane dehydrogenation reacted with CO2, via the reverse water gas shift reaction, to form CO and water. Under vacuum, FTIR spectra of adsorbed ethene on Zn-ZSM-5 showed stronger adsorption on zinc Lewis acid sites than on Bronsted acid sites. In the presence of steam, strong adsorption of ethene on the zinc Lewis acid sites (nu(C=C) at 1595 cm(-1)) splits the spectra into two absorption bands (at 1650 and 1568 cm(-1)), implying the hydrolysis of Zn(II) sites to form Bronsted acid sites and Zn(OH)(+) sites. Hydrolysis of Zn(II) sites suppresses oligomerization/aromatization reactions. The changes in selectivity are reversible and can be stopped by decreasing water vapor pressure. The results confirm that Zn(OH)(+) sites are effective in ethane dehydrogenation, but the Zn(II) sites are necessary for aromatization. The absence of aromatization reactions in the presence of steam shows that Zn(II) sites catalyze aromatization at faster rates than Bronsted acid sites.
Effect of Metal on the Methanol to Aromatics Conversion over Modified ZSM-5 in the Presence of Carbon Dioxide

Caixia Xu,Binbo Jiang,Zuwei Liao,Jingdai Wang,Zhengliang Huang,Yongrong Yang

DOI: https://doi.org/10.1039/c6ra27104a

IF: 4.036

2017-01-01

RSC Advances

Abstract:Interaction of catalysts' active sites with CO2affected the aromatics yield of the MTA reaction over modified catalysts in a CO2atmosphere.
Enhancing Methane Conversion by Modification of Zn States in Co-Reaction of MTA

Yue Yu,Zhixiang Xi,Bingjie Zhou,Binbo Jiang,Zuwei Liao,Yao Yang,Jingdai Wang,Zhengliang Huang,Jingyuan Sun,Yongrong Yang

DOI: https://doi.org/10.3390/catal11121540

IF: 3.9

2021-01-01

Catalysts

Abstract:Limited by harsh reaction conditions, the activation and utilization of methane were regarded as holy grail reaction. Co-reaction with methanol, successfully realizing mild conversion below 450 °C, provides practical strategies for methane conversion on metal-loaded ZSM-5 zeolites, especially for highly efficient Zn loaded ones. However, Zn species, regarded as active acid sites on the zeolite, have not been sufficiently studied. In this paper, Zn-loaded ZSM-5 zeolite was prepared, and Zn was modified by capacity, loading strategy, and treating atmosphere. Apparent methane conversion achieves 15.3% for 1.0Zn/Z-H2 (16.8% as calculated net conversion) with a significantly reduced loading of 1.0 wt.% against deactivation, which is among the best within related zeolite materials. Besides, compared to the MTA reaction, the addition of methane promotes the high-valued aromatic production from 49.4% to 54.8%, and inhibits the C10+ production from 7.8% to 3.6%. Notably, Zn2+ is found to be another active site different from the reported ZnOH+. Medium strong acid sites are proved to be beneficial for methane activation. This work provides suggestions for the modification of the Zn active site, in order to prepare highly efficient catalysts for methane activation and BTX production in co-reaction with methanol.
Enhancing Low-Temperature Methane Conversion on Zn/ZSM-5 in the Presence of Methanol by Regulating the Methanol-to-aromatics Reaction Pathway

Zhixiang Xi,Bingjie Zhou,Yue Yu,Binbo Jiang,Zuwei Liao,Jingdai Wang,Zhengliang Huang,Yao Yang,Jingyuan Sun,Yongrong Yang

DOI: https://doi.org/10.1039/d0cy00449a

IF: 6.177

2020-01-01

Catalysis Science & Technology

Abstract:The co-reaction method provides an efficient strategy for methane conversion under mild conditions, which is of urgent importance for direct valorization of natural gas to liquid hydrocarbons.
Ethane Conversion in the Presence of CO2 over Co-based ZSM-5 Zeolite: Co Species Controlling the Reaction Pathway

Hongyao Guo,Huan He,Changxi Miao,Weiming Hua,Yinghong Yue,Zi Gao

DOI: https://doi.org/10.1016/j.mcat.2022.112155

IF: 4.6

2022-01-01

Molecular Catalysis

Abstract:Two cobalt-based ZSM-5 catalysts CoZ-IE and CoZ-IM were prepared by ion-exchange and incipient wetness impregnation method, respectively, and characterized by XRD, N-2 adsorption, TEM, XPS, UV-vis, H-2-TPR and Py-IR. The catalytic performance towards ethane conversion over the two catalysts in the presence of CO2 was compared. Despite of their similar textual properties and Co contents, the product distributions over the two catalysts were quite different. Ethylene with high selectivity of 95% formed over CoZ-IE while syngas was produced as the main product on CoZ-IM, indicating dry reforming becomes the dominant reaction pathway instead of dehydrogenation. The difference pathway can be ascribed to the different nature of Co species in two catalysts. The isolated Co2+ anchored at zeolitic framework in CoZ-IE is quite stable and can only act as Lewis acid sites for ethane dehydrogenation. In contrast, the cobalt oxides on the zeolitic surface in CoZ-IM can proceed oxidation-reduction cycles in the CO2-C2H6 system, facilitating the activation of CO2 and the scission of C-C bonds, leading to the dry reforming of ethane.
Promoting Effect of ZnO on the Catalytic Performance of CoZSM-5 for CO 2 -Assisted Dehydrogenation of Ethane

Huan He,Zhengxi Zou,Weiming Hua,Yinghong Yue,Zi Gao

DOI: https://doi.org/10.1007/s40242-023-3131-0

IF: 3.1

2023-01-01

Chemical Research in Chinese Universities

Abstract:A series of ZnO-modified cobaltous ion exchanged ZSM-5 catalysts is prepared using incipient wetness impregnation and characterized by X-ray diffraction (XRD), N 2 adsorption, transmission electron microscopy (TEM), UV-Vis diffuse reflectance spectroscopy (DR UV-Vis), X-ray photoelectron spectroscopy (XPS), pyridine-adsorbed Fourier transform infrared (Py-IR) and Raman. Their catalytic performance towards CO 2 -assisted dehydrogenation of ethane to ethylene has been evaluated. The addition of ZnO onto CoZSM-5 obviously improved the yield of ethylene as well as the conversion of CO 2 . The promoting effect is attributed to the good activity of ZnO for the reverse water gas shift (RWGS) reaction, which enhances the coupling between RWGS and ethane dehydrogenation.
CO2 Assisted Ethane Dehydrogenation over Co-exchanged ZSM-5 and ZSM-11 Zeolites: Effect of Al Spatial Distribution

Hongyao Guo,Huan He,Changxi Miao,Weiming Hua,Yinghong Yue,Zi Gao

DOI: https://doi.org/10.1016/j.apcata.2022.118569

IF: 5.723

2022-01-01

Applied Catalysis A General

Abstract:A series of cobalt catalysts loaded on ZSM-5 and ZSM-11 zeolites with different aluminum spatial distribution were prepared by wet ion-exchanged method and characterized by XRD, N2 adsorption, SEM, 27Al MAS NMR, H2-TPR, Py-IR, XPS and diffuse reflectance UV–vis. Their catalytic performance in CO2 assisted dehydrogenation of ethane to ethylene has been evaluated. These catalysts display both superior activity and selectivity, with maximum ethane conversion of 51.3% and ethylene yield of 46.3%. Characterization results show that the excellent catalytic performance results from the high dispersion of cobaltous species stabilized on the exchange sites of zeolitic framework, which is positive correlated with the amount of divalent Co ions located in the internal channels (i.e. α-type and γ-type). The promotional effect of CO2 on stability can be attributed to the removal of coke deposition through Boudouard reaction. The activity is not enhanced by CO2 since the reverse water-gas shift reaction is not evident here.
Coupling CO2 Reduction with Ethane Aromatization for Enhancing Catalytic Stability of Iron-Modified ZSM-5

Zhenhua Xie,Elaine Gomez,Dong Wang,Ji Hoon Lee,Tiefeng Wang,Jingguang G. Chen

DOI: https://doi.org/10.1016/j.jechem.2021.08.005

IF: 13.1

2022-01-01

Journal of Energy Chemistry

Abstract:The shale gas revolution and the carbon-neutrality goal are motivating the landscape toward the synthesis of value-added chemicals or fuels from underutilized ethane with the assistance of greenhouse gas CO 2 . Combining ethane aromatization with CO 2 reduction offers an opportunity to directly produce liquid products for facile separation, storage, and transportation. In the present work, Fe/ZSM-5 catalysts showed promise in the simultaneous CO 2 reduction and ethane aromatization at atmospheric pressure and 873 K. The catalysts were further investigated using X-ray diffraction (XRD) and X-ray absorption fine structure (XAFS) measurements under in-situ conditions, indicating that most of Fe species existed in the form of Fe oxides and a portion of Fe was incorporated into the ZSM-5 framework generating Lewis acid sites. Both types of Fe species remained almost unchanged under reaction conditions, contributing to an enhanced aromatization activity of Fe/ZSM-5. The effects of CO 2 and steam on the acid sites and in turn aromatization activity were also investigated by transient studies, which exhibited a reversible modification behavior. Moreover, CO 2 was identified to be critical to enhance coke resistance and in turn catalyst stability. This work highlights the feasibility of using CO 2 to assist the upgrading of abundant ethane from shale gas to aromatics over non-precious Fe-based zeolite catalysts.
Promoting Effect of ZnO on the Catalytic Performance of CoZSM-5 for CO2-Assisted Dehydrogenation of Ethane

Huan He,Zhengxi Zou,Weiming Hua,Yinghong Yue,Zi Gao

DOI: https://doi.org/10.1007/s40242-023-3131-0

IF: 3.1

2023-09-01

Chemical Research in Chinese Universities

Abstract:Aseries of ZnO-modified cobaltous ion exchanged ZSM-5 catalysts is prepared using incipient wetness impregnation and characterized by X-ray diffraction (XRD), N 2 adsorption, transmission electron microscopy (TEM), UV-Vis diffuse reflectance spectroscopy (DR UV-Vis), X-ray photoelectron spectroscopy (XPS), pyridine-adsorbed Fourier transform infrared (Py-IR) and Raman. Their catalytic performance towards CO 2 -assisted dehydrogenation of ethane to ethylene has been evaluated. The addition of ZnO onto CoZSM-5 obviously improved the yield of ethylene as well as the conversion of CO 2 . The promoting effect is attributed to the good activity of ZnO for the reverse water gas shift (RWGS) reaction, which enhances the coupling between RWGS and ethane dehydrogenation.

chemistry, multidisciplinary
Unraveling the mechanism of ethane oxidative dehydrogenation and the important role of CO 2 over Pt-Zn/ZSM-5 catalysts

Huahua Fan,Xiaowa Nie,Chunshan Song,Xinwen Guo

DOI: https://doi.org/10.1016/j.apcata.2024.119800

IF: 5.723

2024-05-17

Applied Catalysis A General

Abstract:This work studies the reaction mechanism and the role of CO 2 in ethane dehydrogenation to ethene over two types of Pt-Zn/ZSM-5 catalysts. The calculation results demonstrate that the Pt-Zn sites have different roles, and Zn 6 Pt 1 /ZSM-5 is more active than Pt 3 Zn 1 /ZSM-5 due to more efficient Pt-Zn sites for dehydrogenation with the assistance of framework O of ZSM-5. CO 2 reacts with H- species generated from ethane dehydrogenation and creates new and facile H-consuming routes, thus promoting the reaction. The positive effect of CO 2 is more significant over Zn 6 Pt 1 /ZSM-5 than Pt 3 Zn 1 /ZSM-5 owing to the largely reduced barrier of rate-limiting step. Zn 6 Pt 1 /ZSM-5 greatly suppresses the competitive side reaction of CO 2 with ethyl species, thus becoming a promising catalyst for ethene generation. This work deepens the mechanistic understanding of CO 2 -assisted dehydrogenation of light alkanes over Pt-Zn/ZSM-5 catalysts and unravels the important role of CO 2 , providing a useful reference for future catalyst design.

chemistry, physical,environmental sciences
CO2-assisted ethane aromatization over zinc and phosphorous modified ZSM-5 catalysts

Chunyan Tu,Huahua Fan,Dong Wang,Ning Rui,Yonghua Du,Sanjaya D. Senanayake,Zhenhua Xie,Xiaowa Nie,Jingguang G. Chen

DOI: https://doi.org/10.1016/j.apcatb.2021.120956

2022-05-01

Abstract:The tandem reactions of CO2-assisted oxidative dehydrogenation and aromatization (CO2-ODA) of ethane were investigated over ZSM-5 modified with zinc (Zn) and phosphorus (P) by experimental studies and DFT calculations. The nature of active Zn species and their interaction with P were elucidated for understanding Zn/P-ZSM-5 catalyzed CO2-ODA reaction of ethane. Compared to the direct dehydrogenation and aromatization (DDA) reaction, the Zn/P-ZSM-5 catalyst possessed higher ethane conversion, enhanced aromatics yield, and better stability in the CO2-ODA reaction. The presence of CO2 reduced the carbon deposition, stabilized the Zn species, and thereby facilitated the generation of more liquid aromatics in CO2-assisted ethane aromatization. In situ characterization and DFT calculations provided insight into the mechanisms of CO2-ODA over the Zn/P-ZSM-5 catalyst.

chemistry, physical,engineering, chemical, environmental
CO2-Assisted in situ hydrogen extraction for highly selective aromatization of n-Hexane over Zn modified HZSM-5 catalyst

Xiaobo Chen,Delun Ren,Hao Yan,Zhiqiang Li,Xinyang Zhang,Bo Luan,Yaowei Wang,Huibing Shi,Haiying Jiang,Yuhang Hu,Xue Hu,Aijie Zhang,Mingyuan Dong,Xin Zhou,Xiang Feng,Yibin Liu,Chaohe Yang

DOI: https://doi.org/10.1016/j.fuel.2023.128712

IF: 7.4

2023-10-01

Fuel

Abstract:Controlling the evolution of H species in CO2-assisted alkane activation represents an opportunity for simultaneously upgrading light alkanes and greenhouse gas CO2. Herein, we successfully realized the highly selective aromatization of n-hexane by the assistance of CO2 over Zn modified HZSM-5 catalyst. Multi-characterizations demonstrated that the introduction of CO2 could timely remove the in situ H originated from the C-H activation of n-hexane and cyclohexane through the dynamic evolution of the pentagonal coordination Zn-OH+-(CO)-O-Zn structure. On this basis, hydrogen transfer between olefins and aromatics is effectively inhibited, and the binding between π electrons of benzene ring and hydrogen proton is weakened, accelerating the generation and desorption of BTEX. Therefore, the Zn/ZSM-5-CO2 displays a record high 49.7% BTEX yield, which is nearly 10% higher than that of the Zn/ZSM-5-N2 (40.3%). In addition, the loss of medium strength Lewis acid caused by in situ H reduction of Si(Al)-O-Zn structure is significantly reduced, ensuring its superior catalytic stability under long-term conditions. These results may provide some insights for the profitable utilization of petrochemical resources to aromatics over zeolites.

energy & fuels,engineering, chemical
Coking and modification of MgO on Ga2O3/HZSM-5 for dehydrogenation of ethane to ethylene

Chao Yu,Feng Qin,Desheng Xiong,Lei Hou,Wei Shen,Hualong Xu

2011-01-01

Acta Chimica Sinica

Abstract:Coking, decoking and modification of MgO on Ga2O3/HZSM-5 for dehydrogenation of ethane to ethylene are investigated by Laser Raman, TG-MS and NH3-TPD etc. The results demonstrate that coking and cracking of ethane can occur easily on the strong acidic sites. The formed graphitic coke is difficult to be removed in the reaction process, that is the main reason for deactivation of the catalyst. Modification of MgO can greatly reduce the amount of the strong acidic sites of the catalyst, which enhances the stability of the catalyst due to inhibiting the coking rate. Cracking of ethane is also greatly inhibited over MgO-Ga2O3/HZSM-5 catalyst, and consequently the selectivity of ethylene is improved. Steam containing air atmosphere can improve the efficiency of decoking, especially for the graphitic coke. The catalytic activity is restored effectively under H2O-air flow at 420°C.
The migration of Zn species on Zn/ZSM-5 catalyst during the process of ethylene aromatization

Rui Geng,Yacong Liu,Jie Gao,Yanxia Guo,Mei Dong,Sen Wang,Weibin Fan,Jianguo Wang,Zhangfeng Qin

DOI: https://doi.org/10.1039/d2cy00661h

2022-01-01

Abstract:The Zn species in the Zn/ZSM-5 catalyst undergo reciprocal transformation of ZnO clusters and ZnOH + during the ethylene aromatization process. They then migrate to form large-grain ZnO on the outer surface, and finally lost as Zn vapor. Zn-Modified ZSM-5 zeolites are widely used in the ethylene aromatization reaction, but they suffer from rapid deactivation owing to the leaching of active zinc species. In this work, the structure, composition, and evolution manner of Zn species in different reaction stages of ethylene aromatization were investigated by XAS, TEM, XRD, ICP, and XPS. The results show that in the initial stage of the reaction, cationic zinc originated from the interaction between ZnO clusters and protons in ZSM-5 zeolite is the main component and dominant active site. With the progress of the reaction, the reciprocal transformation among zinc cations, the ZnO cluster inside the channel, and ZnO crystals outside the surface of zeolite, occurred with the formation of metallic Zn species that are responsible for not only the transformation but also the migration of Zn species. The amount of ZnOH + species in the exchange position increased in the initial stage, which promoted the generation of aromatics, and then decreased owing to the weakening of the interaction between Zn species and the zeolite framework, forming ZnO species inside and outside the channel. In the deactivation stage, ZnO particles became the main components, accompanied by the loss of zinc species by metallic sublimation, which led to the decline of the catalytic performance of Zn/ZSM-5.

chemistry, physical
Room-Temperature Activation of Methane and Direct Formations of Acetic Acid and Methanol on Zn-ZSM-5 Zeolite: A Mechanistic DFT Study

Muhammad Haris Mahyuddin,Seiya Tanaka,Yoshihito Shiota,Kazunari Yoshizawa

DOI: https://doi.org/10.1246/bcsj.20190282

IF: 5.1214

2020-03-15

Bulletin of the Chemical Society of Japan

Abstract:Zn-ZSM-5 zeolite is a promising catalyst that activates methane at room temperature without the need of a high-temperature pre-oxidation step, which is required for Fe- and Cu-ZSM-5 to form Fe- and Cu-oxo active sites. While two distinct structures of Zn active site, namely [Zn–O–Zn]2+ and Zn2+, were experimentally proposed, the mechanism of how the C–H bond of methane is cleaved is still an intense debate. In addition, the mechanism for moderate-temperature formation of acetic acid by CO2 insertion to the CH4-reacted Zn-ZSM-5 is unclear and the possibility of methanol formation in the presence of an oxidant has never been explored. In the present study, we performed density functional theory (DFT) calculations on the periodic structure of Zn-ZSM-5 zeolite to investigate and clarify these issues. We found that the C–H bond of methane is preferably cleaved on the mononuclear Zn2+ active site through a heterolytic, non-radical mechanism, where the resultant CH3 is bound to the Zn center (Zn–CH3) in the closed-shell singlet state. A good agreement with the reported experimental C–H activation barrier is achieved and plausible mechanisms for the CO2 insertion to and N2O decomposition on the Zn–CH3 bond forming acetic acid and methanol, respectively, are discussed. This study provides a theoretical prediction of an alternative metal-exchanged zeolite catalyst for the low-temperature continuous process of methane selective oxidation to methanol.The mechanisms for room-temperature CH4 activation and subsequent moderate-temperature CH3COOH formation from CO2 insertion on Zn-ZSM-5 zeolite are clarified. Also, an alternative formation of CH3OH from N2O decomposition is predicted to be as facile as the CH3COOH formation.

chemistry, multidisciplinary
Isolated Pt Atoms Stabilized by Ga2O3 Clusters Confined in ZSM-5 for Nonoxidative Activation of Ethane

Xiaomeng Dou,Kailang Li,Kun Zhang,Chaofeng Zhu,Debora M Meira,Yang Song,Peng He,Liang Zhang,Lichen Liu

DOI: https://doi.org/10.1021/jacsau.4c00480

IF: 8

2024-08-26

JACS Au

Abstract:Selective activation of light alkanes is an essential reaction in the petrochemical industry for producing commodity chemicals, such as light olefins and aromatics. Because of the much higher intrinsic activities of noble metals in comparison to non-noble metals, it is desirable to employ solid catalysts with low noble metal loadings to reduce the cost of catalysts. Herein, we report the introduction of a tiny amount of Pt (at levels of hundreds of ppm) as a promoter of the Ga2O3 clusters encapsulated in ZSM-5 zeolite, which leads to ∼20-fold improvement in the activity for ethane dehydrogenation reaction. A combination of experimental and theoretical studies shows that the isolated Pt atoms stabilized by small Ga2O3 clusters are the active sites for activating the inert C-H bonds in ethane. The synergy of atomically dispersed Pt and Ga2O3 clusters confined in the 10MR channels of ZSM-5 can serve as a bifunctional catalyst for the direct ethane-benzene coupling reaction for the production of ethylbenzene, surpassing the performances of the counterpart catalysts made with PtGa nanoclusters and nanoparticles.
Study on Aromatization of Ethylene on Zn/ZSM-5 Zeolite Catalyst

Weizhong Qian

2009-01-01

Abstract:Zn/ZSM-5 catalyst was prepared for the study of process of ethylene aromatization without oxygen in a fixed bed reactor.The effects of Si/Al ratio of ZSM-5 zeolite,Zn content of the catalyst,reaction temperature,WHSV,and partial pressure of ethylene on conversion rate of ethylene,selectivity of aromatics and stability of the catalyst were specifically studied.The preferred reaction conditions were as follow:the Si/Al ratio of ZSM-5 zeolite was 150,zinc content of catalyst 2%,reaction temperature 500℃,and WHSV 3000 mL/(g-h).As a consequence,the yield of aromatics was over 60%,with an outstanding stability of the catalyst.
Cobaltous Oxide Supported on MFI Zeolite As an Efficient Ethane Dehydrogenation Catalyst

Hongyao Guo,Changxi Miao,Weiming Hua,Yinghong Yue,Zi Gao

DOI: https://doi.org/10.1016/j.micromeso.2020.110791

IF: 5.876

2021-01-01

Microporous and Mesoporous Materials

Abstract:Cobalt catalysts supported on submicron ZSM-5 with different Si/Al ratio have been prepared and characterized by XRD, N2 adsorption, SEM, MAS NMR, XPS, UV–vis, Py-IR and H2-TPR. They are effective for direct dehydrogenation of ethane to ethylene. HZSM-5 supported catalyst is far more active than NaZSM-5 and SBA-15 supported ones with same Co content. The optimal catalyst exhibited an ethane conversion of 54.5% with 87.8% selectivity to ethylene. The dispersed cobaltous species play a vital role in dehydrogenation, which were formed by in situ reduction of Co3O4 and CoOx species during the initial reaction period. Higher amount of cobaltous species can be obtained on the support having stronger interaction with the loaded Co species, resulting in an enhancement in catalytic activity. The strong interaction can also stabilize the cobaltous species, preventing the over-reduction of cobaltous species to metallic Co during the reaction which leads to deactivation.
Cr/ZSM-5 for Ethane Dehydrogenation: Enhanced Catalytic Activity Through Surface Silanol

Yanhu Cheng,Changxi Miao,Weiming Hua,Yinghong Yue,Zi Gao

DOI: https://doi.org/10.1016/j.apcata.2016.12.025

IF: 5.723

2017-01-01

Applied Catalysis A General

Abstract:Dehydrogenation of ethane to ethylene in the presence of CO2 was investigated over CrOx catalysts supported on ZSM-5 with different crystallite sizes, including nanometer, submicron and micrometer. These catalysts behave differently in the dehydrogenation reaction, but no relationship between the activity and crystallite size of ZSM-5 was found. XPS, UV-vis, laser Raman and HR-TEM studis show that the better activity comes from better CrOx dispersion on ZSM-5 surface. The characterization results of ZSM-5 supports by N-2 adsorption, SEM, XRD, XRF, Al-27 and Si-29 MAS NMR reveal that the difference of the dispersion is associated with their surface properties, not with the textural ones. Silanols on the surface play an important role in dispersing the CrOx active species. Silanol nests are more helpful in efficient CrOx dispersion than terminal silanols, which subsequently result in higher dehydrogenation activity. (C) 2016 Elsevier B.V. All rights reserved.
Steam catalytic cracking and lump kinetics of naphtha to light olefins over nanocrystalline ZSM-5 zeolite

Emad N. Al-Shafei,Ali N. Aljishi,Zaidoon M. Shakoor,Mohammed Z. Albahar,Mohammad F. Aljishi,Ahmed Alasseel

DOI: https://doi.org/10.1039/d3ra03157h

IF: 4.036

2023-09-01

RSC Advances

Abstract:This study investigates the reaction pathways and kinetics to comprehend the catalytic cracking of dodecane, a heavy naphtha model compound, over the nanocrystalline ZSM-5 catalyst in the presence and absence of steam with the aim of increasing olefin production. The nanocrystalline zeolite was characterized using XRD and BET, and the surface acidity was measured by NH 3 -TPD and Py-FTIR. The steam treated ZSM-5 contributed to an increase in pore volume with extra-framework alumina, resulting in highly catalytic active sites and hence higher olefin selectivity. The high conversion of dodecane (>90%) was achieved during catalytic cracking in the presence and absence of steam. In the presence of steam, the short pores of nano ZSM-5 led to an increase in the naphtha-to-olefin conversion with lesser dry gas and coke formation. The activation energies of primary cracking in the presence and absence of steam were slightly different. Lower activation energies through secondary cracking routes and higher reaction rate constants were obtained via assisted-steam catalytic cracking, promoted the selectivity towards light olefin products. Meanwhile the hydrogenation and alkylation reactions toward LPG and C5+ were favored in the absence of steam. Moreover, the ZSM-5 nano zeolite pores promoted more β-scission reactions, resulting in higher selectivity towards ethylene and dry gas.

chemistry, multidisciplinary

Effect of steam and CO<sub>2</sub> on ethane activation over Zn-ZSM-5

Effect of steam and CO2 on ethane activation over Zn-ZSM-5

Effect of Metal on the Methanol to Aromatics Conversion over Modified ZSM-5 in the Presence of Carbon Dioxide

Enhancing Methane Conversion by Modification of Zn States in Co-Reaction of MTA

Enhancing Low-Temperature Methane Conversion on Zn/ZSM-5 in the Presence of Methanol by Regulating the Methanol-to-aromatics Reaction Pathway

Ethane Conversion in the Presence of CO2 over Co-based ZSM-5 Zeolite: Co Species Controlling the Reaction Pathway

Promoting Effect of ZnO on the Catalytic Performance of CoZSM-5 for CO 2 -Assisted Dehydrogenation of Ethane

CO2 Assisted Ethane Dehydrogenation over Co-exchanged ZSM-5 and ZSM-11 Zeolites: Effect of Al Spatial Distribution

Coupling CO2 Reduction with Ethane Aromatization for Enhancing Catalytic Stability of Iron-Modified ZSM-5

Promoting Effect of ZnO on the Catalytic Performance of CoZSM-5 for CO2-Assisted Dehydrogenation of Ethane

Unraveling the mechanism of ethane oxidative dehydrogenation and the important role of CO 2 over Pt-Zn/ZSM-5 catalysts

CO2-assisted ethane aromatization over zinc and phosphorous modified ZSM-5 catalysts

CO2-Assisted in situ hydrogen extraction for highly selective aromatization of n-Hexane over Zn modified HZSM-5 catalyst

Coking and modification of MgO on Ga2O3/HZSM-5 for dehydrogenation of ethane to ethylene

The migration of Zn species on Zn/ZSM-5 catalyst during the process of ethylene aromatization

Room-Temperature Activation of Methane and Direct Formations of Acetic Acid and Methanol on Zn-ZSM-5 Zeolite: A Mechanistic DFT Study

Isolated Pt Atoms Stabilized by Ga2O3 Clusters Confined in ZSM-5 for Nonoxidative Activation of Ethane

Study on Aromatization of Ethylene on Zn/ZSM-5 Zeolite Catalyst

Cobaltous Oxide Supported on MFI Zeolite As an Efficient Ethane Dehydrogenation Catalyst

Cr/ZSM-5 for Ethane Dehydrogenation: Enhanced Catalytic Activity Through Surface Silanol

Steam catalytic cracking and lump kinetics of naphtha to light olefins over nanocrystalline ZSM-5 zeolite