Abstract:Oxygen-steam gasification of biomass is a promising technology because of its ability to improve syngas quality and reduce energy consumption. In this study, a fixed-bed reactor is employed to assess the effects of inherent alkali and alkaline earth metals (AAEMs) on the catalytic gasification of candlenut wood with large particle size under the oxygen-steam atmosphere. Two grain directions, radial and axial, are considered for candlenut wood. Various characterization techniques, SEM, X-ray CT, BET, and FTIR, are employed to analyze biochar samples. GC-MS and GC are determined to tar and syngas respectively. The results show that char yield from biomass with axial grain is higher. Acid-washing removes alkali metals (K and Na) better from biomass with axial grain than radial grain, and vice versa for alkaline earth metals (Ca and Mg). In terms of the gasified chars derived from acid-washed biomass, AAEMs content gradually decreases along the end surface and radial direction, which could also be observed from the 3D reconstruction of X-ray CT images. In all samples, micropores (0-10 μm) dominate and are distributed along the grain direction. In general, pores of 20-30 μm and above 30 μm comprise a minor proportion. Inherent AAEMs facilitate an augmentation in char yield as well as BET and total pore volume of gasified char. AAEMs and grain direction have a slight effect on functional groups of gasified chars. Certain organic matter species and content in tar are remarkably affected by the grain direction, since the discrepancies of pore structure and specific surface area. Acid-washing pretreatment augments the content and organic species of M2-M4 compounds (containing 2-4 benzene rings) in the tar. K and Na significantly boost the char steam gasification, water-gas shift, and steam-tars reforming reactions. A decrement in concentrations of H 2 (14.49% and 13.35%), CH 4 (0.51% and 0.89%), and CO 2 (2.32% and 1.37%) in syngas derived from acid-washed samples are acquired, respectively, compared to that of biomass samples with radial and axial grains. However, a reduction of 4.09% and 1.53% in syngas calorific value could be obtained. The C n H x volume fraction is significantly affected by grain direction and AAEMs, with axial grain yielding a higher volume fraction of C 2 H 4 (49.07%), C 2 H 2 (71.29%), and C 3 H 8 (127.36%) from acid-washed sample than that of radial grain.

Catalytic effects of inherent AAEM on char gasification: A mechanism study using in-situ Raman

Effects of AAEMs on the char heterogeneous structure evolution during Zhundong coal pyrolysis: Insights from micro-Raman spectroscopy

Combined impacts of intrinsic alkali and alkaline earth metals and chemical structure on reactivity of low-rank coal char: New explanation for the role of water-soluble AAEMs during pyrolysis and gasification

Effects of Inherent AAEMs on Catalytic Gasification of Biomass with Large Particle Size under Oxygen-Steam Atmosphere

Effects of Char Chemical Structure and AAEM Retention in Char During the Gasification at 900 °C on the Changes in Low-Temperature Char-O 2 Reactivity for Collie Sub-Bituminous Coal

Catalytic effect and kinetic mechanism of alkali metal carbonates on the reduction reaction of biochar with iron oxide

Impacts of intrinsic alkali and alkaline earth metals on chemical structure of low-rank coal char: Semi-quantitative results based on FT-IR structure parameters

Effects of volatiles and active AAEMs interaction with char on char characteristics during co-pyrolysis

Effect of active alkali and alkaline earth metals on the reactivity of co-gasification char from coal and corn straws

Catalytic Mechanism of Ion-Exchanging Alkali and Alkaline Earth Metallic Species on Biochar Reactivity During CO2/H2O Gasification

Effect of Alkali and Alkaline Earth Metals on In-Situ Catalytic Fast Pyrolysis of Lignocellulosic Biomass: A Microreactor Study

Catalytic effect of alkali metal in biomass ash on the gasification of coal char in CO2

Effect of active alkali and alkaline earth metals on physicochemical properties and gasification reactivity of co-pyrolysis char from coal blended with corn stalks

Synergetic Effects of Biochar Structure and AAEM Species on Reactivity of H2O-activated Biochar from Cyclone Air Gasification

Evolution Of Char Structure During In-Situ Biomass Tar Reforming: Importance Of The Coupling Effect Among The Physical-Chemical Structure Of Char-Based Catalysts

Steam Gasification of Sawdust Biochar Influenced by Chemical Speciation of Alkali and Alkaline Earth Metallic Species

Catalytic Effect of Alkali Metals on the Gasification Dissolution Reaction and Deep Reaction Behavior of Metallurgical Cokes.

Influences of Ash-Existing Environments and Coal Structures on CO2 Gasification Characteristics of Tri-High Coal

Influence of inherent hierarchical porous char with alkali and alkaline earth metallic species on lignin pyrolysis

Effect of cellulose, lignin, alkali and alkaline earth metallic species on biomass pyrolysis and gasification

Effect of Pyrolysis Temperature on Char Structure and Chemical Speciation of Alkali and Alkaline Earth Metallic Species in Biochar