Abstract:Recent years have seen increased interest in dedicated exhaust gas recirculation (D-EGR) systems integrated with reciprocating engines. By dedicating one cylinder to operate at fuel rich conditions, hydrogen is generated for use in the remaining cylinders to optimize combustion and mitigate pollutant emissions. In this study, experiments were performed using a rapid compression machine (RCM) to investigate the effects of hydrogen and carbon monoxide on methane ignition and flame propagation at fuel rich and stoichiometric conditions relevant to D-EGR engines. The experiments were conducted over a range of temperatures (T = 860–1080 K) and equivalence ratios (ϕ = 1.0–1.5) and at a pressure of P = 20 atm. The results showed hydrogen addition had little effect on ignition delay time at lower temperatures (T < 950 K), but hydrogen significantly promoted ignition at higher temperatures (T > 950 K). Carbon monoxide had little effect on ignition delay times at all conditions studied. Combustion products were acquired using a fast sampling system and analyzed using gas chromatography. The results showed at ϕ = 1.4 the hydrogen mole fraction was a maximum of 8.0% of the products of rich combustion which was consistent with predictions based on chemical equilibrium calculations and model simulation results. High speed images were taken to quantify the impact of equivalence ratio on flame speed for spark-ignited mixtures in RCM experiments using mixtures similar to those expected in the D-EGR and stoichiometric cylinders. The results indicated the H2 in the D-EGR promoted the combustion process in the stoichiometric cylinder, increasing flame speed and decreasing combustion duration. Specifically, when the equivalence ratio in the D-EGR cylinder was ϕ = 1.3, the flame speed increased by about 40% compared with ϕ = 1.0. However, higher equivalence ratios reduced the flame speed and thus adversely affected combustion in the D-EGR cylinder. The results indicate stability and effectiveness of the combustion in the D-EGR cylinder could be a major concern for D-EGR natural gas engines, and optimizing the equivalence ratio of the D-EGR cylinder is critical for D-EGR to enhance combustion performance in the engine overall.

Effect of hydrogen addition on combustion, performance and emission of stoichiometric compressed natural gas fueled internal combustion engine along with exhaust gas recirculation at low, half and high load conditions

Engine Performance and Emissions for a Heavy-Duty Diesel Engine Converted to Stoichiometric Natural Gas Operation

Numerical Investigation of Methane Number and Wobbe Index Effects in Lean-Burn Natural Gas Spark-Ignition Combustion

An Experimental Study of the Combustion Process in a Natural-Gas Spark-Ignition Engine

Experimental Study on Combustion and Emission Characteristics of a Hydrogen-Enriched Compressed Natural Gas Engine under Idling Condition

Performance and Emission Characteristics of a Spark-Ignition (SI) Hydrogen-Enriched Compressed Natural Gas (HCNG) Engine Under Various Operating Conditions Including Idle Conditions

Performance and Emission Characteristics of a Turbocharged Spark-Ignition Hydrogen-Enriched Compressed Natural Gas Engine under Wide Open Throttle Operating Conditions

Design of Hydrogen Enriched Compressed Natural Gas Engine Fuel System and Test Research

Performance and Emission Characteristics of a Turbocharged CNG Engine Fueled by Hydrogen-Enriched Compressed Natural Gas with High Hydrogen Ratio

Effect of Compression Ratio and Spark Timing on the Power Performance and Combustion Characteristics of an HCNG Engine

Performance, emissions and combustion analysis of hydrogen-enriched compressed natural gas spark ignition engine by optimized Gaussian process regression and neural network at low speed on different loads

Influence of Different Volume Percent Hydrogen/Natural Gas Mixtures on Idle Performance of A Cng Engine

The Effect Of Excess Air Ratio On Performance Of Internal Combustion Engine At Idle Conditions For Different H-2/Cng Ratios

Numerical Investigation of the Effect of Ammonia Addition on the Performance of a Stoichiometric Operated Natural Gas Spark Ignition Engine

Effects of compression ratio on the combustion and emission of a hydrogen enriched natural gas engine under different excess air ratio

Study of Laminar Burning Speed and Calibration Coefficients of Quasi-Dimensional Combustion Model for Hydrogen Enriched Compressed Natural Gas Fueled Internal Combustion Engine along with Exhaust Gas Recirculation

Effects of Chamber Geometry, Hydrogen Ratio and EGR Ratio on the Combustion Process and Knocking Characters of a HCNG Engine at the Stoichiometric Condition

A Rapid Compression Machine Study of Autoignition, Spark-Ignition and Flame Propagation Characteristics of H2/CH4/CO/air Mixtures

Experimental Study on Thermal Efficiency and Emission Characteristics of a Lean Burn Hydrogen Enriched Natural Gas Engine

Experimental investigation and numerical assessment the effects of EGR and hydrogen addition strategies on performance, energy and exergy characteristics of a heavy-duty lean-burn NGSI engine

Numerical Simulation of HCNG Engine on GT-Power