Abstract:Methyl methacrylate (MMA) typically produced from the petroleum-based ethylene or isobutene selective oxidation route is a significantly important chemical widely used in industrial manufacture. Herein, an innovative and highly efficient liquid-phase catalytic system, cobalt complex catalyzed O2-interrupted hydrogen borrowing pathways, was developed for direct synthesis of MMA from methyl propionate and methanol at mild conditions, considering the problems of poor selectivity, rapid catalyst deactivation, and formaldehyde polymerization existed in one-step aldol reaction of methyl propionate with formaldehyde at 350–380 °C. The yield and selectivity of MMA could reach up to 50.2% and 81.8% at 60 °C and 1 atm. Thermodynamic calculations and analysis for this novel transformative process were conducted to confirm the feasibility and reasonability for MMA production at low temperature (below 100 °C). On the basis of the reaction networks proposed according to the experimentally detected products, studies on the kinetic informatics of this new process were conducted. The formaldehyde oxidation, aldol condensation of methyl/t-butyl propionate with formaldehyde and transesterification of t-butyl propionate/methacrylate with methanol are first-order dependent on their reactant concentrations. While the methanol dehydrogenation and transesterification of methyl propionate/methacrylate with t-BuOK are first-order dependent on the concentration of only methanol and t-BuOK. With the understanding of kinetic behavior of these reaction steps composed, the global kinetic model was established to describe this catalytic system and the corresponding parameters including pre-exponential factor and activation energy were calculated. The oxidative dehydrogenation of methanol to formaldehyde, with the highest activation energy of 84 kJ/mol, was the kinetic-relevant step, while the aldol condensation of methyl propionate with formaldehyde showed the lowest energy of 36 kJ/mol.

Mechanistic Insight into Methacrolein Formation from Formaldehyde and Propionaldehyde

Mechanism and Kinetic Study on Synthesis of Methacrolein Catalyzed by Amine/Acid

Synthesis of Methacrolein by Condensation of Propionaldehyde with Formaldehyde

Catalytic Synthesis of Methacrolein via the Condensation of Formaldehyde and Propionaldehyde with L-Proline Intercalated Layered Double Hydroxides

Kinetic and mechanistic insights into the roles of protonated morpholine species and weak acidic environment in methylacrolein production catalyzed by morpholine/acid

Approaching sub-ppm-level asymmetric organocatalysis of a highly challenging and scalable carbon–carbon bond forming reaction

Microwave Enhanced Catalytic Hydration of Acrolein to 3-Hydroxypropionaldehyde Using Simultaneous Cooling: Experimental and Theoretical Studies

Synthesis of Methyl Acrylate by Aldol Condensation of Methyl Acetate with Formaldehyde Over Al2O3-Supported Barium Catalyst

Acetalization of Carbonyl Compounds with 2,2,4-Trimethyl-1,3-pentanedio Catalyzed by Novel Carbon Based Solid Acid Catalyst

Zirconium-Modified Cs/SiO2 Catalyst for Synthesis of Methyl Acrylate Via Aldol Condensation of Methyl Acetate with Formaldehyde

Theoretical Study On The Diels-Alder Reaction Between 2-Methylacrolein And Cyclopentadiene Catalyzed By A Cationic Oxazaborolidine Lewis Acid

Mechanistic Insights into Electroreductive C-C Coupling Between CO and Acetaldehyde into Multicarbon Products.

Studies on synthesis of methyl glycolate and methyl methoxy acetate from the coupling of formaldehyde and methyl formate

Mechanistic Study on the Formation of the Alkyl Acrylates from CO2, Ethylene and Alkyl Iodides over Nickel-based Catalyst

Kinetic and thermodynamic studies on direct synthesis of methyl methacrylate from methyl propionate and methanol catalyzed by highly efficient cobalt complex at mild conditions

Catalyst-controlled and visible-light-induced acylmethylation and bromoacylmethylation of Morita-Baylis-Hillman acetates with a-bromo ketones: access to highly functionalized 1,5-dicarbonyl compounds

Direct synthesis of p-methyl benzaldehyde from acetaldehyde via an organic amine-catalyzed dehydrogenation mechanism

The Production of Formaldehyde and Hydroxyacetone in Methacrolein Photooxidation: New Insights into Mechanism and Effects of Water Vapor

Synthesis of 1,3-Propanediol by Cross Aldol Reaction and Hydrogenation of Formaldehyde with Acetaldehyde

Substrate-controlled chemoselective assembly of coumarins and Morita–Baylis–Hillman alcohols from salicylaldehydes with acrylates

Formation of Acrylates from Ethylene and Co2 on Ni Complexes: A Mechanistic Viewpoint from A Hybrid Dft Approach