Abstract:Metal phosphides have been identified as a promising class of materials for the catalytic upgrading of bio-oils, which are renewable and potentially inexpensive sources for liquid fuels. Herein, we report the facile synthesis of a series of solid, phase-pure metal phosphide nanoparticles (NPs) (Ni2P, Rh2P, and Pd3P) utilizing commercially available, air-stable metal phosphine complexes in a one-pot reaction. This single-source molecular precursor route provides an alternative method to access metal phosphide NPs with controlled phases and without the formation of metal NP intermediates that can lead to hollow particles. The formation of the Ni2P NPs was shown to proceed through an amorphous Ni-P intermediate, leading to the desired NP morphology and metal-rich phase. This low-temperature, rapid route to well-defined metal NPs is expected to have broad applicability to a variety of readily available or easily synthesized metal phosphine complexes with high decomposition temperatures. Hydrodeoxygenation of acetic acid, an abundant bio-oil component, was performed to investigate H-2 activation and deoxygenation pathways under conditions that are relevant to ex situ catalytic fast pyrolysis (high temperatures, low pressures, and near-stoichiometric H-2 concentrations). The catalytic performance of the silica-supported metal phosphide NPs was compared to the analogous incipient wetness (IW) metal and metal phosphide catalysts over the range 200-500 degrees C. Decarbonylation was the primary pathway for H-2 incorporation in the presence of all of the catalysts except NP-Pd3P, which exhibited minimal productive activity, and IW-Ni, which evolved H-2. The highly controlled NP-Ni2P and NP-Rh2P catalysts, which were stable under these conditions, behaved comparably to the IW-metal phosphides, with a slight shift to higher product onset temperatures, likely due to the presence of surface ligands. Most importantly, the NP-Ni2P catalyst exhibited H-2 activation and incorporation, in contrast to IW-Ni, indicating that the behavior of the metal phosphide is significantly different from that of the parent metal, and more closely resembles that of noble metal catalysts.

Pt/HAP Catalyzed Direct Decarboxylation of Lipid to Alkanes Via Stabilization and Synergism Effect

Highly Efficient Conversion of Oleic Acid to Heptadecane Without External Hydrogen Source over Atomic Layer Deposited Bimetallic NiPt Catalysts

Hydrothermal decarboxylation and hydrogenation of fatty acids over Pt/C.

Catalytic hydrothermal deoxygenation of palmitic acid (vol 3, pg 311, 2010)

Water-mediated Promotion of the Catalytic Conversion of Oleic Acid to Produce an Alternative Fuel Using Pt/C Without a H2 Source

Enhanced Stability of Pt/C by the Atomic Layer Deposition of Porous MOx for the Decarboxylation of Oleic Acid

Exceptional Selectivity to Olefins in the Deoxygenation of Fatty Acids over an Intermetallic Platinum–Zinc Alloy

Upgrading Phenolic Compounds and Bio-Oil Through Hydrodeoxygenation Using Highly Dispersed Pt/TiO2 Catalyst

Selective Decarbonylation of Fatty Acids over the PtCo3Nx@NC Catalyst to Produce Long-Chain Olefins

Hydrodecarboxylation of fatty acids into liquid hydrocarbons over a commercial Ru/C catalyst under mild conditions

Catalytic Transfer Hydrogenation with Methanol over Pt/C Catalyst for Synergistic Hydrothermal Hydrogenation of Palmitic Acid

A Facile Molecular Precursor Route to Metal Phosphide Nanoparticles and Their Evaluation As Hydrodeoxygenation Catalysts

Efficient solvent-free hydrodeoxygenation of bio-lipids over bifunctional NiW catalyst: Manipulations of surface-active sites by thermal pretreatment

Hydrothermal Hydrogenation/deoxygenation of Palmitic Acid to Alkanes over Ni/activated Carbon Catalyst

Direct Selective Hydrogenation of Fatty Acids and Jatropha Oil to Fatty Alcohols over Cobalt-Based Catalysts in Water

Manipulating catalytic pathways: deoxygenation of palmitic acid on multifunctional catalysts

Hydrodeoxygenation of bio-oil model compounds over Ni- and Pt-catalysts supported on hydrophobized halloysite nanotubes

Enhanced photocatalytic alkane production from fatty acid decarboxylation via inhibition of radical oligomerization

Efficient Hydrogenation of Various Renewable Oils over Ru-HAP Catalyst in Water

Hydrothermal hydrogenation/deoxygenation of palmitic acid to alkanes over Ni/AC catalyst

Hydrodeoxygenation of Water-Insoluble Bio-Oil to Alkanes Using a Highly Dispersed Pd–Mo Catalyst