Pretreatment of Sugarcane Bagasse with Deep Eutectic Solvents Affect the Structure and Morphology of Lignin

Qinghua Ji,Xiaojie Yu,Peiwen Wu,Abu El-Gasim A. Yagoub,Li Chen,Abdullateef Taiye Mustapha,Cunshan Zhou

DOI: https://doi.org/10.1016/j.indcrop.2021.114108

IF: 6.449

2021-01-01

Industrial Crops and Products

Abstract:Elucidating the structural characteristics and changes of lignin during biorefining is considerably significant for lignin valorization. Deep eutectic solvent (DES), as a green solvent, has shown excellent performance in extracting high-purity lignin from lignocellulose with high yields. However, further utilization of the multiple novels DES remains to be a severe challenge to the biorefinery process. In this study, alkaline lignin (AL), which was separated from sugarcane (Sacharum officinale L.) bagasse (SCB), was pretreated by a ternary DES (TDES) (choline chloride (ChCl)-lactic acid (LA)/oxalic acid (OA)-AlCl3 center dot 6H(2)O) at 120 degrees C for 6 h to obtain regenerated lignin. The properties and structural transformation of lignin during the TDES pretreatment were investigated by gel-permeation chromatography (GPC), two-dimensional-heteronuclear single quantum correlation nuclear magnetic resonance (2D-HSQC NMR), P-31 NMR, Fourier transform infrared spectroscopy (FT-IR), and thermogravimetric analysis (TGA). Finally, the degradation products recovered from TDES pretreatment were also analyzed by pyrolytic gas chromatography-mass spectrometry (Py-GC-MS). It was found out that the yields of the regenerated lignin pretreated by ChCl-LA-AlCl3 center dot 6H(2)O and ChCl-OA-AlCl3 center dot 6H(2)O were 65.40 and 55.43 %, respectively. In contrast, the contents of phenolic hydroxyl groups in lignin were 2.54 and 2.84 mmol g(-1), respectively, the content of aliphatic hydroxyl groups were 0.91 and 0.79 mmol g(-1), respectively. In addition, it is found that the depolymerization of the lignin fraction was the dominant reaction during the TDES pretreatment. Based on the observed results, a possible pathway of chemical conversion of SCB lignin during the TDES pretreatment process was proposed. This study shows that the pretreatment with hydrated metal chloride-based TDES provides a promising condition for generating of the value-added lignin in the current biorefinery process.