Abstract:Globally, livestock and poultry production leads to total emissions of 7.1 Gigatonnes of CO2-equiv per year, representing 14.5% of all anthropogenic greenhouse gas emissions. Anaerobic digestion (AD) is one of the sustainable approaches to generate methane (CH4) from manure, but the risk of ammonia inhibition in high-solids AD can limit the process. Our objective was to develop a two-stage (liquid–solid) AD biotechnology, treating chicken (CM) + dairy cow (DM) manure mixtures at 20 °C using adapted liquid inoculum that could make livestock farming more sustainable. The effect of organic loading rates (OLR), cycle length, and the mode of operation (particularly liquid inoculum recirculation-percolation mode) was evaluated in a two-stage closed-loop system. After the inoculum adaptation phase, aforementioned two-stage batch-mode AD operation was conducted for the co-digestion of CM + DM (Total Solids (TS): 48–51% and Total Kjeldahl Nitrogen (TKN): 13.5 g/L) at an OLR of 3.7–4.7 gVS/L.d. Two cycles of different cycle lengths (112-d and 78-d for cycles 1 and 2, respectively) were operated with a CM:DM mix ratio of 1:1 (w/w) based on a fresh weight basis. Specific methane yield (SMY) of 0.35 ± 0.11 L CH4g/VSfed was obtained with a CH4 concentration of above 60% for both the cycles and Soluble Chemical Oxygen Demand (CODs) and volatile solid (VS) reductions up to 85% and 60%, respectively. For a comparison purpose, a similar batch-mode operation was conducted for mono-digestion of CM (TS: 65–73% and TKN: 21–23 g/L), which resulted in a SMY of 0.52 ± 0.13 L CH4g/VSfed. In terms of efficiency towards methane-rich biogas production and ammonia inhibitions, CM + DM co-digestion showed comparatively better quality methane and generated lower free ammonia than CM mono-digestion. Further study is underway to optimize the operating parameters for the co-digestion process and to overcome inhibitions and high energy demand, especially for cold countries.

Exploring the Combined Effect of Total Ammonia Nitrogen, Ph and Temperature on Anaerobic Digestion of Chicken Manure Using Response Surface Methodology and Two Kinetic Models.

Effect of Ammonia Concentration on Hythane (H2 and CH4) Production in Two-Phase Anaerobic Digestion

Examining a Pretty Simple and Low Cost Method for Modeling of Biogas Production from Biodegradable Solids

Additional ratios of hydrolysates from lignocellulosic digestate at different hydrothermal temperatures influencing anaerobic digestion performance

Effect of Temperature on Co-Anaerobic Digestion of Chicken Manure and Empty Fruit Bunch: A Kinetic Parametric Study

[Performance and Process Kinetics of Pilot-Scale ANAMMOX Bioreactor under Different Water Temperatures].

Investigation on the Interactive Effects between Temperature and Chemical Composition of Organic Wastes on Anaerobic Co-Digestion Performance

Influences of Temperature and Substrate Particle Content on Granular Sludge Bed Anaerobic Digestion

Ammonia inhibition in anaerobic digestion of organic waste: a review

Effect of Ammonia and Nitrate on Biogas Production from Food Waste Via Anaerobic Digestion

Enhancing Performance and Stability of Anaerobic Digestion of Chicken Manure Using Thermally Modified Bentonite.

Kinetic of Ph Control in Anaerobic Digestion of Organic Fraction of Municipal Solid Waste in a Batch Reactor

Microbial Response Behavior to Powdered Activated Carbon in High-Solids Anaerobic Digestion of Kitchen Waste: Metabolism and Functional Prediction Analysis.

Inhibition Mechanisms of Ammonia and Sulfate in High-Solids Anaerobic Digesters for Food Waste Treatment: Microbial Community and Element Distributions Responses

Ammonia-induced constraints on butyrate degradation in anaerobic digestion: Impact of ammonia levels and pH conditions, and recovery behaviour

Processing High-Solid and High-Ammonia Rich Manures in a Two-Stage (Liquid-Solid) Low-Temperature Anaerobic Digestion Process: Start-Up and Operating Strategies

Effects of Thermal Treatment on High Solid Anaerobic Digestion of Swine Manure: Enhancement Assessment and Kinetic Analysis.

Modification of Anaerobic Digestion Model No. 1 for modeling anaerobic digestion of cattle manure with changing solids retention time

Evaluation of anaerobic co-digestion of dairy manure with food wastes via bio-methane potential assay and CSTR reactor.

Effect of temperature change on anammox activity