Abstract:Compared with film condensation, dropwise condensation based on droplet growth can significantly improve the condensing equipment’s water collection and thermal efficiency in the vapor condensate system. Therefore, as a critical behavior affecting the evolution of dropwise condensation, research on droplet growth is of great significance to further understanding the evolutionary characteristics and heat transfer mechanism of dropwise condensation. In this paper, a model for simulating the entire evolution process of dropwise condensation is improved and constructed, and the evolution process of dropwise condensation with different condensation nucleus densities on the vertical wall is simulated based on certain assumptions. Moreover, parameters such as evolution rate and size contribution are proposed to measure droplet growth’s influence on the evolution process of dropwise condensation. In the simulation, the Cassie model was used to describe the condensation growth of droplets. The neighbor finding algorithm and conservation law are coupled to simulate the coalescence growth process of droplets. Through the comparison of the theoretical model and experimental results, it is indicated that the simulation method in this paper is highly reliable. The simulation results demonstrate that more than 95% of the maximum droplet size of dropwise condensation is derived from coalescence growth, and its growth rate can characterize the evolution rate of dropwise condensation. The evolution rate reveals a linear growth trend with the increase of condensate nucleus density, and the average heat flux shows an increasing trend followed by a decreasing trend, reaching the peak, qaverage = 30.5 kW·m−2, at the NS = 5 × 109 m−2. The surfaces with a high coalescence frequency can increase the contribution of the coalescence growth to the maximum droplet size more effectively and, conversely, the contribution of condensation growth is weakened, which is less than 1% at the NS = 7.5 × 109 m−2.

Numerical Simulation on the Growth of Polydisperse Fine SiO2 Particles by Water Vapor Condensation

Visualization and Numerical Investigations on Heterogeneous Nucleation of Water Vapor on the Surface of SiO2, Fe2O3 and CaSO4 Particles

Model and Numerical Simulation for Adsorption Phase Reaction and Crystallization

Growth characteristics of submicron particles by water vapor condensation in the multi-section growth tube

Numerical simulation of growth performance of insoluble PM10 by vapor heterogeneous condensation

Heterogeneous Condensation of Water Vapor on Particles at High Concentration

Heterogeneous Condensation of Water Vapor on Fine SiO2 Particles in Two-Section Growth Tube

Effect of supersaturation distribution on particle heterogeneous condensation in growth tube

Establishment of Nucleation and Growth Model of Silica Nanostructured Particles and Comparison with Experimental Data

Heterogeneous Condensation Process Observed by Environmental Scanning Electron Microscopy (ESEM): on Smooth Single Aerosol Particle

Number simulation of heterogeneous condensation of water vapor on fine particles in growth tube by population balance model

A Numerical Study on Growth Mechanism of Dropwise Condensation

Numerical Simulation of Vapor Dropwise Condensation Process and Droplet Growth Mode

Molecular Dynamics Simulation of Heterogeneous Nucleation of Water Vapor on Nanosolid Particles

Heterogeneous Condensation on Fine Particles of Water Vapor in a Moderated Growth Tube

Numerical Simulation of the Collision Behaviors of Binary Unequal-Sized Droplets at High Weber Number

Numerical Investigation of Effects of Particle Properties on Nucleation Process in a Sulfuric Acid–water Vapor Mixture: Homogeneous Versus Heterogeneous

Monte Carlo simulation for precipitation and growth behaviors in supersaturated liquid

Heterogeneous condensation of magnetized water vapor on fine SiO 2 particles.

Effects of Surface Topography of SiO2 Particles on the Heterogeneous Condensation Process Observed by Environmental Scanning Electron Microscopy

Study on the Three-Stage Growth of Silica Nanoparticles Prepared by the Drop-by-drop Precipitation Method