Abstract:Long-distance oil pipeline is the most economical way to transport the crude oil and liquid chemical raw materials. The spillage liquid may enter the covered drain to form the flame spread over sub-flash liquid fuel. In this paper, a self-designed fuel-storable quartz glass pipe with the size of 100 cm long and 10 cm inner diameter is used to simulate a long-narrow confined space. The n -butanol flame spread behavior in the circular confined space is investigated by controlling the sealing ratio of the tube. The results show that the flame spreading behavior in the confined space is significantly different from that in the open space. There is the flame shuttle behavior at the sealing ratio β = 10% and the self-extinguishing behavior of the flame occurs at β = 55%. As the sealing ratios β > 10%, there is an obvious "retraction" behavior, resembling flame spreading over a hydrocarbon fuel in an open environment. However, the controlling mechanism is essentially different. For flame spread over butanol in a tube, the flame retreating is due to the insufficient oxygen supply. By contrast, for the flame spread over hydrocarbon fuel in an open space, the flame retreating is due to the evident difference of the flashpoint and fire point of the hydrocarbon fuel. The flame pulsation frequency increases from 2.0 to 5.7 Hz as the sealing ratio increases from β = 2% to 40%; then, it decreases to 1.3 Hz at β = 55%. The increase of the pulsation frequency in the initial stage indicates that the flame burns inadequately due to the reduced oxygen supply in the large sealing ratio. At β = 2%, the instantaneous velocity alternates between a low speed of 1–3 cm s −1 and a high speed of 5–8 cm s −1 , with an average velocity of 1.9 cm s −1 . This flame spreading behavior is regarded as the quasi-uniform propagation. At β = 45%, the average velocity reaches 2.3 cm/s. At β = 55%, the average velocity of flame is 0.54 cm s −1 , indicating that the flame is difficult to spread forward. When the flame passes through the oxygen concentration sensor, there is a low oxygen concentration valley in the range of 1–5%. In middle area of the tube, the combustion can maintain owing to the oxygen concentration below 12%. This paper provides some theoretical support and guidance for fire safety and rescue in the long-narrow confined space.

Experimental Study on Flame Propagation Through Stratified Crude Oil Vapor in a Horizontal Duct

Flame Propagation in Gasoline Vapor–air Mixtures with Concentration Gradient in a Closed Duct

Experimental Investigation of Low-Temperature Autoignition in Turbulent Premixed Swirling Flames

Comparative Research on Laminar Flame Propagation for Four C8 Fuels

Study of the Ignition Characteristics of Light Fractions of Crude Oil and Their Surrogate Fuels under a Range of Low-to-Medium Temperatures

Experimental Study on a Comparison of Typical Premixed Combustible Gas-Air Flame Propagation in a Horizontal Rectangular Closed Duct.

Comparative Study of the Effects of Ignition Location on the Flame Propagation Characteristics and Spectral Properties of a Methane–air Premixed Gas in a Vertical Pipeline

Experimental Investigation of Flame Behaviors of Turbulent Diffusion Flames with Different Ullage Heights

Ignition of a Single Lubricating Oil Droplet in Combustible Ambient Gaseous Mixture under High-Temperature and High-Pressure Conditions

Flame expansion behavior induced by a water droplet impacting on burning and stratified oil-water pool

Experimental Study on Flame Height of Two Oil Tank Fires under Different Lip Heights and Distances

Experimental Study on the Premixed Laminar Flames for Toluene-Air Mixtures

Investigation of pulsating behavior and oxygen concentration of flame spread over sub-flash n-butanol fuel in a circular tube

Laminar Flame Propagation and Nonpremixed Stagnation Ignition of Toluene and Xylenes

Premixed Flame Propagation of Natural Gas/Air Mixtures in a Closed Rectangular Tube

Effects of gas concentration and obstacle location on overpressure and flame propagation characteristics of hydrocarbon fuel-air explosion in a semi-confined pipe

Experimental study on the interaction between flame propagation and wall film in a confined vessel

Experimental Study on the Dynamic Combustion Behavior of Thin Fuel Layer Caused by Instantaneous Leakage of Ethanol and Gasoline

The Evolution of Flame Length for the Oil Tank Fire with Different Top Cover Widths and Lip Heights

Experimental investigation on the burning behaviors of thin-layer transformer oil on a water layer

Propagation of Combustion Front within Fractured Shale and Its Influence on Shale Structure and Crude Oil Properties: An Experimental Study