Abstract:During surgery, the use of a high-frequency electric knife produces smoke, which can be harmful to the health of indoor medical staff and patients. The quantity and particle size distribution of smoke particles produced by different tissues may vary. Understanding the release characteristics of these smoke particles is necessary to clarify their impact on the surgical environment and to seek effective smoke control methods. A previous comparative analysis of human and pig tissues revealed that they share similar water and fat compositions in certain anatomical regions. In this study, we investigated the emission characteristics of smoke particles from various tissues of pigs (skeletal muscle, liver, kidney, skin, and subcutaneous fat) under different operating powers of an electric knife. We measured the indoor particle number concentration (particle concentration), and estimated the PM2.5 mass concentration (PM2.5 concentration), particle size distribution, and emission rate of the smoke particles. The study obtained the particle emission rates of different tissues under different electric knife operating powers, results of which showed that (1) during the operation of the electric knife, mainly small particles below 1 μm are produced. Among them, particles of 0.3 μm were the most abundant, with a particle concentration level of up to 109 particles/m3, accounting for 85.17-97.64% of the total particle number, and as the particle size increased, the particle concentration and percentage decreased significantly. (2) The water and fat compositions of different tissues influenced the indoor particle concentration and emission rate of the smoke emitted by the electric knife. Among different tissues, subcutaneous fat tissue had the lowest particle concentration and emission rate. (3) The electric knife operating power mainly affected particles below 1 μm, and except for kidney tissue, the indoor concentration and emission rate of these particle sizes were positively correlated with the power. The experimental results can provide data reference for the use of high-frequency electric knives in surgeries involving different human tissues in the operating room.

Bacteria in Surgical Smoke: A Self-controlled Laboratory Study Using Porcine Spinal Tissues.

In vivo and in vitro study of the potential hazards of surgical smoke during cervical cancer treatment with an ultrasonic scalpel

Surgical smoke: a matter of hygiene, toxicology, and occupational health

467 Analysis of Surgical Smoke Generated by Electrocautery and Standard Surgical Mask Protection in a Simulated Neurosurgical Operating Room Using a Post-mortem Porcine Model for Laminectomy Exposures

Surgical Smoke: Still an Underestimated Health Hazard in the Operating Theatre

Removal of Hazardous Surgical Smoke Using a Built-in-Filter Trocar: A Study in Laparoscopic Rectal Resection

Quantitative Chemical Analysis of Surgical Smoke Generated During Laparoscopic Surgery With a Vessel-Sealing Device

Hazards of surgical smoke from electrocautery: A critical review of the data

Distribution of ultrafine aerosols and volatile organic compounds from surgical smoke during electrocauterization

The risk of COVID-19 transmission by laparoscopic smoke may be lower than for laparotomy: a narrative review

Analysis and visualization of the research progress on surgical smoke

Surgical smoke and its components, effects, and mitigation: a contemporary review

High-frequency electric knife smoke particles: An experimental study on factors influencing emission characteristics

Chemical composition of smoke produced by open versus laparoscopic surgery for cholecystectomy

Many Common Pathogens are Present in the Operative Room Air During Surgery

Surgical smoke: Risk assessment and mitigation strategies

Sources and components of volatile organic compounds in breast surgery operating rooms

Evaluation of Fine Particles in Surgical Smoke from an Urologist’s Operating Room by Time and by Distance

Surgical Masks As Source of Bacterial Contamination During Operative Procedures

The research on the effect of temperature of electro-surgical unit to surgical smoke distribution in theatre-in vitro and simulation study

Research on transmission risk exposure of pathogenic microorganisms in anesthesia procedures