Abstract:Chemical-looping combustion (CLC) is a new combustion technology with inherent separation of CO2. Most of the previous investigations on CLC of solid fuels were conducted under atmospheric pressure. A pressurized CLC combined cycle (PCLC-CC) system is proposed as a promising coal combustion technology with potential higher system efficiency, higher fuel conversion, and lower cost for CO2 sequestration. In this study pressurized CLC of coal with Companhia Valedo Rio Doce (CVRD) iron ore was investigated in a laboratory fixed bed reactor. CVRD iron ore particles were exposed alternately to reduction by 0.4g of Chinese Xuzhou bituminous coal gasified with 87.2% steam/N2 mixture and oxidation with 5% O2 in N2 at 970°C. The operating pressure was varied between 0.1MPa and 0.6MPa. First, control experiments of steam coal gasification over quartz sand were performed. H2 and CO2 are the major components of the gasification products, and the operating pressure influences the gas composition. Higher concentrations of CO2 and lower fractions of CO, CH4, and H2 during the reduction process with CVRD iron ore was achieved under higher pressures. The effects of pressure on the coal gasification rate in the presence of the oxygen carrier were different for pyrolysis and char gasification. The pressurized condition suppresses the initial coal pyrolysis process while it also enhances coal char gasification and reduction with iron ore in steam, and thus improves the overall reaction rate of CLC. The oxidation rates and variation of oxygen carrier conversion are higher at elevated pressures reflecting higher reduction level in the previous reduction period. Scanning electron microscope and energy-dispersive X-ray spectroscopy (SEM–EDX) analyses show that particles become porous after experiments but maintain structure and size after several cycles. Agglomeration was not observed in this study. An EDX analysis demonstrates that there is very little coal ash deposited on the oxygen carrier particles but no appreciable crystalline phases change as verified by X-ray diffraction (XRD) analysis. Overall, the limited pressurized CLC experiments carried out in the present work suggest that PCLC of coal is promising and further investigations are necessary.

Chemical-looping combustion of Victorian brown coal using mixed oxygen carriers of iron and manganese oxides

Chemical Looping Combustion (CLC) of Two Victorian Brown Coals – Part 1: Assessment of Interaction Between CuO and Minerals Inherent in Coals During Single Cycle Experiment

Reduction Rate Enhancements for Coal Direct Chemical Looping Combustion with an Iron Oxide Oxygen Carrier

Use of Fe2O3-Containing Industrial Wastes As the Oxygen Carrier for Chemical-Looping Combustion of Coal: Effects of Pressure and Cycles

Chemical Looping Combustion (CLC) of Two Victorian Brown Coals – Part 2: Assessment of Interaction Between CuO and Minerals Inherent in Coals During Multi Cycle Experiments

Synergetic effects of mixed copper–iron oxides oxygen carriers in chemical looping combustion

Chemical Looping Combustion Characteristics of Coal with Fe2O3 Oxygen Carrier

Pressurized chemical-looping combustion of coal using an iron ore as oxygen carrier in a pilot-scale unit

Reactivity investigation on chemical looping gasification of coal with Iron-Manganese based oxygen carrier

Application of Mn–Fe Composite Oxides Loaded on Alumina as Oxygen Carrier for Chemical Looping Gasification

Performance and Kinetics of Iron-Based Oxygen Carriers Reduced by Carbon Monoxide for Chemical Looping Combustion

Pressurized chemical-looping combustion of coal with an iron ore-based oxygen carrier

Interaction Between Fe-based Oxygen Carriers and N-Heptane During Chemical Looping Combustion

Development of Sinter-Resistant Core–Shell LaMnxFe1–xO3@mSiO2 Oxygen Carriers for Chemical Looping Combustion

Evaluation of Fe-Ni Composite Oxygen Carrier in Coal Chemical Looping Gasification

Chemical Looping Combustion Characteristics of Coal with a Novel CaSO4–Ca2CuO3 Mixed Oxygen Carrier

Chemical Looping Combustion of a Typical Lignite with a CaSO4–CuO Mixed Oxygen Carrier

MgO–Kaolin-Supported Manganese Ores As Oxygen Carriers for Chemical Looping Combustion

Research and Development of Coal-fueled Chemical Looping Combustion