Abstract:Abstract Nano particle-assisted engineered water is one of the newest hybrid methods of Enhanced Oil Recovery (EOR) that is gaining attention in the oil and gas industry. This is attributed to the low cost of the technique and environmental friendliness of the materials involved. Low salinity and ions adjustment of the injection brine has been reported to be very useful for improving oil production in carbonates, and application of nanoparticles (NPs) to improve oil recovery via different mechanisms such as wettability alteration, interfacial tension reduction, disjoining pressure and viscosity modification. This paper therefore investigates the combined effects of these two techniques on oil-brine-rock (OBR) interactions in carbonate reservoirs. Caspian Sea Water salinity of 13000 ppm was synthesized in the laboratory, potential determining ions such as Mg2+, Ca2+ and SO42- were adjusted to obtain the desired engineered waters used as dispersant for SiO2 nanoparticle. A series of experiments were performed ranging from zeta potential, interfacial tension, contact angle, electron scanning environmental imaging, pH analysis and particle size to determine the optimum formulation of engineered low salinity brine and nanoparticle. The salinities and concentration of NP considered in this experimental study ranges between (3,250 - 40,000) ppm and (0.05 - 0.5) wt.%, respectively. It was observed that optimum homogenization time for achieving stability of the chosen nanofluid without using stabilizer is 45 minutes. Four times sulphate and calcium ions in the engineered water reduced the contact angle from 163 to 109 and 151 to 118 degrees respectively. However, in the presence of NP, the contact angle further reduced to a very low values of 5 and 41 degrees. This confirms the combined effects of EW and that of nanofluid (NF) in altering wettability from the hydrophobicity state to hydrophilicity one that rapidly improves oil recovery in carbonate reservoir. IFT measurements were made between oil and formation brine as well as between oil and different EWs at room temperature. The Formation water has the least value of interfacial tension- 15mN/m. Four times diluted sea water spiked with four times sulphate is denoted as 4dsw4S. The zeta potential values showed dsw4S-NF to be the most stable, whereas EW-NF spiked with 4 times Mg2+ show detrimental effects on NF stability. The nanoparticles sizes were measured to be less than 50 nm. Rheological studies of the EW-NF at different temperatures (25, 40, 60 and 80 degrees Celsius) shows similar trend of Newtonian and non-Newtonian behavior at shear rate less than 100 and above 100 per seconds respectively. We conclude that spiking calcium ion and sulphate ion into the injected brine in combination with 0.1wt% NP yielded the wettability alteration in carbonate rock samples. The significant reduction in wettability is attributed to the combined effects of the active mechanisms present in the hybrid method and is considerably better than each standalone technique.

Electrokinetic Mechanisms and Synergistic Effect on Ion-Tuned Wettability in Oil-Brine-Rock Systems

Electrokinetic Mechanism of Wettability Alternation at Oil-Water-rock Interface

Competitive Effects of Interfacial Interactions on Ion-Tuned Wettability by Atomic Simulations

A comprehensive insight on the impact of individual ions on Engineered Waterflood: With already strongly water-wet sandstone

Mechanism analysis of injection technique of water composition modification for enhanced oil recovery

Effect of Electrokinetics and Thermodynamic Equilibrium on Low-Salinity Water Flooding for Enhanced Oil Recovery in Sandstone Reservoirs

Review of Low Salinity Waterflooding Mechanisms: Wettability Alteration and Its Impact on Oil Recovery

Molecular dynamics for ion-tuned wettability in oil/brine/rock systems

Insights From Ion Adsorption and Contact-Angle Alteration at Mineral Surfaces for Low-Salinity Waterflooding

Experimental Investigation on the Interfacial Characteristics of Tight Oil Rocks Induced by Tuning Brine Chemistry

Enhancement of Oil Transport Through Nanopores Via Cation Exchange in Thin Brine Films at Rock-Oil Interface

Wettability Alteration and Enhanced Oil Recovery in Carbonate Porous Media by Tuning Waterflood Chemistry

Micromechanical mechanism of oil/brine/rock interfacial interactions based on first-principles calculations

Insights into mechanism of low salinity water flooding in sandstone reservoir from interfacial features of oil/brine/rock via intermolecular forces

Synergistic Effects of Engineered Water-Nanoparticle on Oil/Brine/Rock Interactions in Carbonates

Dynamics of electrostatic interaction and electrodiffusion in a charged thin film with nanoscale physicochemical heterogeneity: Implications for low-salinity waterflooding

Ionic Interactions at the Crude Oil–Brine–Rock Interfaces Using Different Surface Complexation Models and DLVO Theory: Application to Carbonate Wettability

Surface Complexation Modelling of Potential Determining Ions Sorption on Oil/Brine and Brine/Rock Interfaces

Nanofluid-Induced Wettability Gradient and Imbibition Enhancement in Natural Porous Media: A Pore-scale Experimental Investigation

Impacts of inorganic salts ions on the polar components desorption efficiency from tight sandstone: A molecular dynamics simulation and QCM-D study

A mechanistic experimental study on the combined effect of Mg2+, Ca2+, and SO42- ions and a cationic surfactant in improving the surface properties of oil/water/rock system