Abstract:This study investigated the impact of varying total ammonia nitrogen (TAN) feed levels along with water temperature decreases on the performance of nitrifying moving bed biofilm reactor (MBBR) at 1 °C and its recovery at 3 °C. Five MBBR reactors were operated with different TAN concentrations as water temperature decreased from 20 to 3 °C: reactor R1 at 30 mg N/L, reactor R2 at 20 mg N/L, reactor R3 at 15 mg N/L, reactor R4 at 10 mg N/L and reactor R5 at 0 mg N/L. The corresponding biofilm characteristics were also analyzed to understand further nitrifying MBBR under different TAN feeding scenarios. The findings revealed that the higher TAN levels were before reaching 1 °C, the better nitrification performance and the more biomass grew. However, the highest TAN concentration (30 mg N/L) might negatively affect the nitrification performance, the activity of nitrifiers, and the growth of biofilms at 1 °C because of the toxic effects of un-ionized or free ammonia (FA). It was observed that the activities of ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB) were affected by FA concentrations ranging from 0.2 to 0.7 mg N/L at 1 °C, but they could gradually be adapted to such inhibitory environment, with NOB recovering more quickly and robustly than AOB. The study identified 20 mg N/L (67 % of maximum influent TAN at 1 °C in R2 as the optimal TAN feeding concentration, achieving over 90 % TAN removal and a surface area removal rate (SARR) of 0.78 ± 0.02 g N/m2·d at 1 °C. Meanwhile, R2 also exhibited the highest biofilm mass, with total solids at 13.3 mg/carrier and volatile solids at 11.3 mg/carrier. As TAN was removed, nitrite accumulation was observed at 1 °C, and higher influent TAN concentrations prior to 1 °C appeared to delay the accumulation. When water temperature increased from 1 °C to 3 °C, nitrification performance improved significantly in all reactors without nitrite accumulation, and the higher TAN feeding in the previous stage led to faster recovery. Compared with 20 °C, biofilm became thinner and denser at 1 °C and 3 °C. Furthermore, this study revealed significant shifts in microbial community composition and nitrifier abundances in response to changes in water temperature and influent TAN levels. The dominant nitrifiers were identified as Nitrosomonadaceae (AOB) and Nitrospiraceae (NOB). At 1 °C, the nitrifier abundances were significantly correlated with SARRs, FA, and biofilm density. R2, which exhibited the best nitrification performance, maintained higher nitrifier abundances at 1 °C.

Thermo-Lability of Nitrifying Activity in Biological Aerated Filter

The impact of temperature on nitrification rate in fixed film biofilters

Temperature Effect on Aerobic Denitrification and Nitrification.

Effects of temperature and pH on nitrification in a seawater biological aerated filter

Biomass Change in Biological Aerated Filter at Low Temperatures

Performance of anammox UASB reactor treating low strength wastewater under moderate and low temperatures

Influence of Temperature on Treating Nitrification of High Ammonia Nitrogen Source Water in Biological Carbon Filter

The nitrogen removal characterization of a cold-adapted bacterium: <i>Bacillus simplex</i> H-b

Deciphering the effect of temperature reduction on the biofilm in partial nitritation-anammox system: Insights from microbial community to metabolic pathways

Response and recovery of nitrifying moving bed biofilm reactor systems exposed to 1°C with varying levels of ammonia starvation

Cold Temperature Effects on Long-Term Nitrogen Transformation Pathway in a Tidal Flow Constructed Wetland.

[Effects of Cold Acclimation on the Activity of Autotrophic Nitrogen Removal in Granular Sludge and Its Bacterial Population Structure]

Effect of Temperature on Structure of Microbial Film and on Effluent Water Characteristics in Aerobic Submerged Biofilter.

[Nitrification and Bioaugmentation of Biological Treatment System of Sewage Treatment Plant at High Temperature in Summer].

Operating Characteristics of Two-stage BAF Process at Extreme Low Temperature

Effects of Temperature on Nitrifying Membrane-Aerated Biofilms: An Experimental and Modeling Study

Cold Temperature Increases Nitrate Accumulation in Pilot-Scale Surface Flow Constructed Wetlands with High Rates of Nitrogen Removal

Treating the filtrate of mainstream anaerobic membrane bioreactor with the pilot-scale sludge-type one-stage partial nitritation/anammox process operated from 25 to 15 °C

Influence of temperature on performance and mechanism of advanced synergistic nitrogen removal in lab-scale denitrifying filter with biogenic manganese oxides

Effect of temperature change on anammox activity

Effect of nitrogen removal of river water treatment using BAF+SPD combined process at low temperature