Energy saving potential analysis on boiler flue gas pre-dried lignite-fired power system:the effect of lignite kinds and unit cooling types

Ming Liu,Xuelian Yang,Xiaoqu Han,Zhaonan Xue,Junjie Yan,Feng Xiao

DOI: https://doi.org/10.3969/j.issn.2095-2783.2014.08.018

2014-01-01

Abstract:To investigate the energy saving adaptation of boiler flue gas pre-dried lignite-fired power system,the energy saving po-tential of 1 000 MW air-cooling and wet-cooling power system units burning different kinds of lignite from Yimin,Dayan,Wu-j ianfang and Baiyinhua were quantitatively analyzed using theoretical analysis method.And the quantitative conclusion of the a-mount of standard coal consumption reduction rate at different flue gas pre-dried lignite-fired power generation system form.Re-sults show that,the higher of water content of lignite,the greater the energy-saving potential of system.Without recoverying of exhaust gas heat recovery of exhaust gas heat,or only recoverying of exhaust gas heat boiler air preheating,energy saving poten-tial of air-cooling unit is slightly larger than the wet-cooling unit.When the condensed water was used in the wet-cooling unit for further recovery of exhaust gas heat energy,its energy saving potential was higher than air-cooling unit.