Abstract:To avoid the energy waste in the production of furnace grade phosphoric acid, a novel phosphoric reactor with circular water wall is designed, which could recover waste heat to produce superheated steam with the help of drum. A three-dimensional mathematical model of phosphorus combustion in the novel phosphoric reactor is developed by incorporating kappa-epsilon turbulence model, eddy dissipation combustion model and P-1 radiation heat transfer model. The streamline field distribution, temperature distribution and species concentration distribution are predicted by numerical simulation. The results show that phosphorus combustion mainly takes place in the injection zone of atomised phosphorus; the maximum combustion temperature and exit temperature are 1790 and 970 K respectively which conform well to practical datum. Meanwhile, the effects of parameters on maximum combustion temperature, smog exit temperature, maximum wall heat flux and averaged wall heat flux of the novel phosphoric reactor with circular water wall are also discussed, including phosphorus consumption, excess air coefficient, wall temperature and radiation absorption coefficient. The predicted results show that maximum combustion temperature, smog exit temperature, maximum wall heat flux and averaged wall heat flux will increase with increasing phosphorus mass flowrate when excess air coefficient is constant. Under the condition of constant phosphorus mass flowrate, the smog exit temperature will increase with increasing excess air coefficient and other parameters will decrease. Wall temperature has a remarkable effect on the smog exit temperature, whereas its effects on other parameters are not obvious. In addition, radiation absorption coefficient has remarkable effects on maximum combustion temperature and maximum wall heat flux in the novel phosphoric reactor.

Development of tail gas close loop and fluorine recovery technology for WPA production

Waste Heat Recovery in the Production of Furnace-Grade Phosphoric Acid

Equipment to Reclaim the Waste Heat of Phosphoric Acid Production by Hot Process and Research on Combustion Temperature

Present Situation and Prospect of Recovery and Utilization of Yellow Phosphorus Tail Gas

Preparation of polyphosphoric acid and recovery of valuable fluorine resources though a microwave intensification flash evaporation process

Development and Cfd Simulation of A Novel Phosphoric Reactor with Waste Heat Recovery

A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

Efficient recovery of fluorine from wet-process phosphoric acid using silicon powder as a new and eco-friendly reagent

Efficient and cost-effective fluorine recovery from liquid-phase wet-process phosphoric acid via two-step precipitation method

Coal power plant flue gas waste heat and water recovery

The Heat Recovery and Utilization in the Production of Furnace-process Phosphoric Acid

A Novel Technical Route Based on Wet Flue Gas Desulfurization Process for Flue Gas Dehumidification, Water and Heat Recovery

Optimization of wet-process phosphoric acid for high-quality phosphogypsum

Designing an efficient fluorine recovery strategy for Wet-Process phosphoric acid purification by disclosing competitive complexation behavior between fluorine species and metal cations

Pilot test on acidic fluoride-containing wastewater treatment in the photovoltaic industry through induced crystallization with a focus on calcium fluoride recovery

On-Site Experimental Study on Low-Temperature Deep Waste Heat Recovery of Actual Flue Gas from the Reformer of Hydrogen Production

A novel flue gas waste heat recovery system for coal-fired ultra-supercritical power plants

Primary Research of a New Zero-Liquid-Discharge Technology of Wet Flue Gas Desulfurization Wastewater by Low-Rank Heat from Flue Gas

Waste heat recovery from coal-fired boiler flue gas: Performance optimization of a new open absorption heat pump

A clean process for phosphorus recovery and gallium enrichment from phosphorus flue dust by sodium carbonate roasting

Waste Heat and Water Recovery System Optimization for Flue Gas in Thermal Power Plants