Effects of Ammonia Stresses on Anaerobic Digestion of Swine Manure
GAO Wen-xuan,ZHANG Ke-qiang,LIANG Jun-feng,SONG Xiang-yu,HAN Bing-ya,DU Lian-zhu
DOI: https://doi.org/10.11654/jaes.2015.10.023
2015-01-01
Abstract:Anaerobic digestion is a commonly used technique for treating livestock manure and producing biogas. However, ammonia gener-ated during the digestion may reduce the efficiency of an anaerobic digestion system. Here a batch experiment was carried out to investigate the effect of ammonia on anaerobic digestion of swine manure by adding ammonia at 0, 400, 800, 1600, 2400, 3200 mg·L-1 and 4000 mg·L-1 under mesophilic conditions(35℃). Cumulative biogas production had no obvious differences at 0~800 mg·L-1 of ammonia concentrations. However, the lag phase appeared and cumulative biogas decreased when ammonia was higher than 2400 mg·L-1. Yields of CH4 were 328.5, 338.1, 323.2, 304.9, 276.2, 124.9 mL·g-1 and 56.1 mL·g-1 VS for 0, 400, 800, 1600, 2400, 3200 mg N·L-1 and 4000 mg N·L-1, respective-ly. The maximum CH4 yield rates were 18.3, 18.4, 17.1 mL·g-1·d-1 at 0, 400 mg N·L-1, and 800 mg N·L-1 of ammonia added, respectively. Increasing ammonia from 3200 mg·L-1 to 4000 mg·L-1 sharply decreased the CH4 yield rates and greatly delayed the peaks. The biodegrad-ability(BAD)of VS at 30 d was 55.6%, 56.7%, 54.5%, 52.4%, 30.6%, 1.6%and 1.3%for 0, 400, 800, 1600, 2400, 3200 mg N·L-1 and 4000 mg N·L-1, respectively. The results from terminal-restriction fragment length polymorphism(T-RFLP)and clone library showed that the relative abundance of acetate-utilizing Methanosaeta decreased with increases in ammonia concentrations, but the abundance of hydro-gen-utilizing Methanosarcina and Methanococcus had an opposite tendency at ammonia range of 400~2400 mg·L-1.