Abstract:In situ methane enrichment method can increase the methane content in biogas, which is a cost-effective technology used for producing bio-methane compared with conventional biogas upgrading technologies. During the in situ methane enrichment process, liquid stream from the anaerobic digester is circulated through a CO2-desorption unit and then returned back to the digester. The most important step in this process is CO2 desorption. In this study we evaluated the effects of different CO2 desorption techniques. Three CO2 desorption methods including air stripping, vacuum extraction and ultrasonic-auxiliary air stripping were studied through experiments. The experiments were conducted under mesophilic (38℃) anaerobic digestion by using synthetic wastewater with glucose and supplemental nutrients. The experimental apparatus included one anaerobic digester with volume of 1 500 mL and two CO2-desorption bottles with volume of 500 mL used for air stripping and vacuum extraction respectively. The results showed that the average volume fraction of methane in biogas reached 76.4%and 78.3%for the air stripping groups (aeration fluxes of 205 mL/min and daily stripping time of 30min), and increased by 17%and 20%compared to the control (65.4%) with the daily recycle rates of liquid stream (DRR) at 0.2 L/(L·d) and 0.4 L/(L·d), respectively. The cumulative methane production is similar to controlled one for the group with DRR of 0.2 L/(L·d). But the cumulative methane production decreased by 15%compared with control one for the group with DRR of 0.4 L/(L·d). In situ methane enrichment effect of the group of CO2 vacuum extraction with 0.1 MPa vacuum maintaining 5 min was slightly lower than that of the air stripping group with aeration flux at 205 mL/min, daily stripping time 20min and DDR 0.2 L/(L·d). The methane volume fraction of biogas in the first group was decreased by 4.6% compared to that of the second group. However, the difference is not significant (P>0.05). The results of experiment of ultrasonic-auxiliary air stripping, with aeration flux of 100 mL/min, daily stripping time of 21 min and ultrasonic frequency of 40 kHz, show that ultrasonic wave can accelerate CO2 air stripping, especially when the concentration of CO2 in the liquid was high. During the initial 3 min of stripping the CO2 removing rate of ultrasonic-auxiliary air stripping group was advanced by 32%compared to air stripping group. The total free CO2 removal amount from the liquid stream was increased by 29.8% compared to air stripping group during the whole stripping time of 21 min. Furthermore, ultrasonic wave has potential advantages on CO2 removing by lowering pH of liquid and increasing anaerobic digestion efficiency through decomposing many complex organic compounds. Therefore, the effect of air stripping and vacuum extraction on methane enrichment has no significance difference, but vacuum extraction has no problem of oxygen inhibition, the control of which is vital for successful running of in situ methane enrichment process of air stripping. Ultrasonic-auxiliary air stripping method has advantages for CO2 desorption due to its unique characteristics of lowering pH, degrading complex compounds and increasing CO2 removal.

Simulation Test of Self-stirring in Dry Anaerobic Fermentation Based on Releasing Pressurized Biogas

Numerical simulation of pressure fluctuation in gas-solids agitated fluidized bed

Dry Anaerobic Fermentation Based on Regulating Biogas Pressure

Study on Scale-Up of Anaerobic Fermentation Mixing with Different Solid Content

Experimental study of self-pressurizing transfer system for cryogenic liquid

Gas bubble behaviors in a gas–solid fluidized bed with an arch agitator

Experimental and simulation study on the surface contact between biogas fermentation liquid and straw material based on hydraulic mixing

[A Novel Quantitative Approach to Study Dynamic Anaerobic Process at Micro Scale].

Research progress of gas dispersion in stirred vessel with medium or high viscosity fluids

Flow Patterns of Super-High-rate Anaerobic Bioreactor

Effect of Air Equivalence Ratio on the Characteristics of Biomass Partial Gasification for Syngas and Biochar Co-Production in the Fluidized Bed

Effect of air mixing on high-solids anaerobic digestion of cow manure: Performance and mechanism

Effects of Gas Supplying Patterns on Aerobic Anaerobic Biogas Production of Rice Straw

Influence of Techniques for Desorption of Carbon Dioxide on in Situ Methane Enrichment During Biogas Fermentation

Study on Side-entering Agitator Flow Field Simulation in Large Scale Biogas Digester

Spiral-Pipe Gas Anaerobic Digester

Effects of Stirring on Semi-dry Anaerobic Digestion of Pig Dung for Biogas Production

Experimental Characteristics of Adding Biogas to Premixed Self-Excited Oscillating Methane Swirling Flames

Improving the efficiency of small-scale wastewater treatment by pneumatic agitation

Experimental determination and numerical simulation of mixing time in a gas–liquid stirred tank

The study of influencing factors to straw mixed with livestock manure anaerobic fermentation