Study on the Nucleation and Growth of Fine Particles in Flue Gas Promoted by Heterogeneous Condensation of Water Vapor

Jingjing BAO,Jialing XU,Jiguo TANG,Guo XIE,Hongtao LIU,Licheng SUN,Hongmin YANG

DOI: https://doi.org/10.15961/j.jsuese.201700305

2017-01-01

Abstract:Traditional dust collecting equipments cannot capture fine particles from coal-fired flue gas efficiently due to their small sizes.A heterogeneous condensation technology was proposed for a wet flue gas desulfurization (WFGD) system to improve its efficiency of removing fine particles.Numerical study was first carried out to present the growth of coal-fired fly ash and inorganic salt particles as nucleation for heterogeneous condensation under supersaturated water vapor environment.The results indicated that the diameter of fine particles increases from tenfold to hundreds of times in a very short time with the presence of heterogeneous condensation of water vapor on the surface of fine particles under a flue gas temperature of 323 K.In addition,higher vapor supersaturation and larger initial particle diameter are beneficial to the grown up of fine particles.Experiments were then conducted to verify the numerical results and evaluate the practical effect of the technology on growth and removal of coal-fired fine particles and inorganic salt particles in a wet flue gas desulfurization system containing supersaturated water vapor with the help of PDA and ELPI.The temperature of desulfurated flue gas was in the range of 40 ～ 50 ℃.The results indicated that fine particles grow larger by 3-5 times in a very short time in the presence of heterogeneous condensation,changing from submicron particles to micron-sized dusty droplets.Hydrophilic inorganic salt particles deliquesce much more easily,forming solution droplets,which could be nucleated and grew up under the condition of saturation degree close to 1.Due to its good ability of capturing these grown dusty droplets,wire-mesh demister was employed to promote the growth and removal of fine particles combined with heterogeneous condensation.The number concentration of fine particle decreases significantly from 9.5 × 106/cm3 to 5 × 106/cm3 and the mass concentration is reduced sharply from 80 mg/m3 to 20 mg/m3.The corresponding removal efficiencies of fine particles are 50% and 75%,respectively.