Abstract:With the aggravation of the energy crisis and environmental problems, the new energy electric vehicle industry has ushered in vigorous development. However, with the continuous increase in car ownership, traffic accidents and other issues have gradually attracted widespread attention. Some existing stability coordination control systems often have problems, such as single stability judgment method and strong coupling between different subsystems. Therefore, based on previous research, it is necessary to further optimize the method of judging the vehicle’s stability state, establish clear coordination rules, and reasonably solve the coupling problem between subsystems. This is of great significance for promoting the further development of the electric vehicle industry. Due to four-wheel-distributed driving and four-wheel-distributed steering electric vehicles having the characteristics of integrated driving, flexible steering, and easy fault-tolerant control, it has unique advantages in improving vehicle stability and is a good carrier for designing and constructing the stability coordination control system. In this paper, four-wheel-distributed driving and four-wheel-distributed steering (4WD-4WS) electric vehicles are taken as the research object, and a coordinated control strategy of four-wheel steering and four-wheel drive is proposed. Firstly, in order to realize the accurate judgment of vehicle stability, based on the vehicle two-degree-of-freedom two-track model and magic tire model, this paper uses the phase plane law to divide the phase plane stability region of the vehicle and introduces the stability quantification index PPS-region for the evaluation of vehicle stability. Secondly, a fuzzy variable parameter active rear-wheel steering controller and a compensated yaw moment controller are designed. Then, for the coupling problem between the two controllers, a coordination rule is proposed based on the stability index PPS-region of the phase plane stability region. Finally, a hardware-in-the-loop testbed is built to verify the feasibility of the coordination control strategy proposed in this paper. Experimental results show that: When the vehicle is in different stable states, according to the divided steady state, the control strategy can be correctly switched to the corresponding control strategy, and the work of each subsystem can be reasonably coordinated. Under the continuous gain sine condition, the control algorithm can reduce the maximum amplitude of the yaw rate error response curve by 73% and the side slip angle error response curve by 85%. Compared with a single stability control system, the coordinated stability control algorithm can improve the control effect of yaw rate and side slip angle by 20% and 62.5%. In the case of double lane-change, the control algorithm can reduce the maximum amplitude of the yaw rate error response curve by 68.5% and the side slip angle error response curve by 57.4%. Compared with a single stability control system, the coordinated stability control algorithm can improve the control effect of yaw rate and side slip angle by 40.6% and 44.7%.

Coordinated control of vehicle yaw and roll stability based on ARS and AFS

A Dynamics Coordinated Control System for 4WD-4WS Electric Vehicles

Enhancement of Vehicle Stability Based on Coordinated Active Rear Steering and Additional Yaw Moment

Integrated Vehicle Chassis Control Based on Direct Yaw Moment, Active Steering and Active Stabiliser

Integrated control of braking-yaw-roll stability under steering-braking conditions

Coordination Strategy Between AFS and ASB with Fault-Tolerant Mechanism for Ground Vehicle

Vehicle stability control based on synergistic effect of active steering and differential braking

Robust Vehicle Yaw Stability Controlby Active Front Steering with Active Disturbance Rejection Controller

Active Front Steering-Based Electronic Stability Control for Steer-by-Wire Vehicles via Terminal Sliding Mode and Extreme Learning Machine

Robust Coordination Control of AFS and ARS for Autonomous Vehicle Path Tracking and Stability

Development of Integrated Control of Electronic Stability Control, Continuous Damping Control and Active Anti-Roll Bar for Vehicle Yaw Stability

Modeling and analysis of vehicle stability region based on Lyapunov and coordinated control

Optimal allocation of tire force based on vehicle stability

Integrated stability control of active aerodynamics and active rear-wheel steering for high-speed vehicle

Yaw Rate and Roll Motion Control of 4IWMD/4WS Vehicle Based on Active Rear Steering and Torque Coordination

Coordinated control scheme of path tracking and yaw stability for four-wheel steering and distributed drive autonomous electric vehicles

New Integrated Vehicle Stability Control of Active Front Steering and Electronic Stability Control Considering Tire Force Reserve Capability

Design of an integrated control system to enhance vehicle roll and lateral dynamics

Fuzzy and Sliding Mode Variable Structure Control of Vehicle Active Steering System

Coordinated control of yaw and roll stability in heavy vehicles considering dynamic safety requirements