Abstract:In this paper, a new ternary non-azeotropic mixture of HFC-161/125/143a (0.15/0.45/0.40 in mass fraction), as a promising mixed refrigerant to R404A, is presented. The ozone depletion potential (ODP) of the new refrigerant is zero and its basic thermodynamic properties are similar to those of R404A, but its global warming potential (GWP) is much smaller than those of R507A and R404A. Meanwhile, theoretical calculations show that, under the working condition I (the average evaporation temperature: −23 °C, the average condensing temperature: 43 °C, the superheat temperature: 28 °C, the subcooling temperature: 5 °C), the volumetric refrigerating effect and specific refrigerating effect of the new mixture are 2.33% and 15.48% higher, respectively, than those of R404A. The coefficient of performance (COP) of the new mixture is 5.19% higher than that of R404A and the pressure ratio of the new mixture is 0.82% lower than that of R404A. Equally, under the working condition II (the average evaporation temperature: −40 °C, the average condensing temperature: 35 °C, the superheating temperature: 30 °C, the subcooling temperature: 5 °C), the volumetric refrigerating effect and specific refrigerating effect of the new mixture are 2.24% and 20.58% higher, respectively, than those of R404A. The COP of the new mixture is 4.60% higher than that of R404A and the pressure ratio of the new mixture is similar to that of R404A. The performances of the new mixture and R404A are compared in a vapor compressor refrigeration apparatus originally designed for R404A under several working conditions (condensing temperatures: 35–45 °C, evaporation temperatures: −40–−20 °C). Experimental results show that the new mixture can obtain a higher COP, by 6.3% to 12.1%, and a lower pressure ratio, by 1.8% to 6.6%, compared to R404A; although the discharge temperature of the new mixture is slightly higher than that of R404A. The advantages of the new mixture will be further verified in the actual system.

Comparison of Tribological Characteristics of Vane-piston Interface between R290 and R410A in Rotary Compressor

Experimental Study on the Tribological Characteristic of Vane–roller Interface of HC290 Rotary Compressor with Mineral Oil

Experimental study of ternary mixture R32/R125/R161 as alternative refrigerant to R407C

Experimental Investigation on Off-Design Characteristics of R290 Rolling Piston Compressor

Cycle Performance Studies on a New HFC-161/125/143a Mixture As an Alternative Refrigerant to R404A

Lubricating Condition Evaluation of the Rotary Compressor under High Ambient Temperature

SIMULATION AND COMPARISON OF AIR-SOURCE HEAT PUMPS USING VARIABLE COMPOSITION AND CONSTANT COMPOSITION MIXTURES OR PURE REFRIGERANT

Experimental Study on P-V Diagram and Valve Displacement of A Hc290 Rotary Compressor

Performance and Refrigerant Mass Distribution of a R290 Split Air Conditioner with Different Lubricating Oils

Lubrication of R290 Rotary Compressor Used in Low-Temperature Air-Water Heat Pumps

Experimental and numerical analysis of the performance of the R290 rotary compressor used in a split-room air conditioner at high ambient temperature

Experimental Analysis on R290 Solubility and R290/oil Mixture Viscosity in Oil Sump of the Rotary Compressor

Performance Research and Improvement of Ultra-High-speed R290 Rotary Compressor

The Modification of the Valves of a Refrigeration Piston Compressor Due to the Refrigerant Change

Experimental Investigation of Oil Retention and Pressure Drop of R32/PVE Oil Mixture in Compressor Suction Line

Analysis on the Reliability of R290 Rotary Compressor in the High Ambient Temperature

Experimental Study on Startup Characteristics of R290 Air Conditioner with Low Lubricant Charge

Mixtures of Lubricants and Ecological Refrigerants under Starved Lubrication Conditions

The Performance Analysis of R32 Rotary Compressor Used for Room Air Conditioners

Thermophysical Properties of R32/advanced PVE Mixture and Parametric Analysis on Oil Transport Characteristic of Compressor Suction Line

Thermodynamic Performance and Compression Characteristics Analysis of Low GWP Refrigerant in Compressors: Experimental Investigation and 0-D/3-D Simulation