Abstract:Foam fluids are widely used in petroleum engineering, but long-standing foam stability problems have limited the effectiveness of their use. The study explores the synergistic effects and influencing factors of SiO2 nanoparticles (SiO2-NPs) with different wettability properties and three different surfactants. The paper investigates the foaming performance of different types of surfactants and analyzes and compares the stability of foam after adding hydrophilic and hydrophobic SiO2-NPs from macroscopic as well as microscopic perspectives, and the effects of temperature and inorganic salts on the stability of mixed solutions. The experimental results show that: 1) hydrophilic nanoparticles can significantly enhance the foam stability of amphoteric surfactants, with a small increase in the foam stability of anionic and cationic surfactants; 2) The concentration of nanoparticles did not have a significant effect on the stability of the cationic surfactants and this conclusion was verified in the experimental results of the surface tension measured below;3) The cationic surfactants showed better temperature resistance at temperatures of 50–90 °C. Both amphoteric surfactant solutions with the addition of hydrophilic SiO2-NPs or hydrophobic SiO2-NPs significantly improved the temperature resistance of the foam at high temperatures. The anionic surfactant solution with hydrophobic SiO2-NPs did not enhance the solution temperature resistance; 4) The surface tension of the surfactant solution gradually increases with increasing concentration of hydrophilic or hydrophobic SiO2-NPs and then levels off; 5) the hydrophilic SiO2-NPs had a significant effect on the salt tolerance of the anionic and amphoteric surfactant solutions. The salt tolerance of cationic surfactant solutions with hydrophobic SiO2-NPs was better than that of surfactants with hydrophilic SiO2-NPs.

Effect of mixed anionic-nonionic reagents on flotation of diaspore and stability of froth

Effects of Single and Mixed Reagent Systems on Improved Diaspore Recovery

Effects of Pb2+ Ions on the Flotation Behavior of Scheelite, Calcite, and Fluorite in the Presence of Water Glass

Study on the flotation separation mechanism of diaspore from kaolinite using mixed NaOL/BHA collector

Synergistic Effect of Fatty Acid and Hydroxamic Acid in Flotation Separation of Apatite and Dolomite

Enhanced Flotation Separation of Iron and Silicon with Branched Block Polyethylene Oxide Polypropylene Oxide and Sodium Oleate: Mechanisms and Flotation Behavior

Flotation enhancement of low-grade bauxite using oxalic acid as surface pretreatment agent

Synergistic effect of a mixture of ethoxyphosphoric esters and sodium oleate in aqueous solutions

Quantitative analysis of surface adsorption reactivity during flotation process by surface complexation model: diaspore and kaolinite

Experimental and simulation study on the flotation separation of smithsonite from dolomite using phosphoryl carboxyl copolymer as a novel depressant

Synergistic Effect of Sodium Dodecyl Benzene Sulfonate on Flotation Separation of Magnesite and Dolomite with Sodium Oleate Collector

Synergistic improvement of foam stability with SiO2 nanoparticles (SiO2-NPs) and different surfactants

Investigations on the synergistic effect of combined NaOl/SPA collector in ilmenite flotation

Adsorption Mechanism of New Mixed Anionic/cationic Collectors in a Spodumene-Feldspar Flotation System

Effect of Dispersants on the Stability of Calcite in Non-Polar Solutions

Enhanced flotation separation of spodumene and albite via selective adsorption of N -hydroxy-9-octadecenamide on the mineral surfaces

Flotation behavior of oleate and dodecylamine as mixed collector for recovery of lithium and rubidium from low-grade spodumene tailings: Experiment, characterization and DFT calculation

Selective flotation separation of spodumene from feldspar using a novel mixed anionic/cationic collector NaOL/ND13

Influence of Different Types of Surfactants on the Flotation of Natural Quartz by Dodecylamine

Solution Chemical Mechanism of Diaspore Flotation Using Anionic Collectors

The synergetic collecting effect of N-oleoyl sarcosine (N-OSS) and dodecylamine (DDA) on the selective flotation of spodumene from albite