Abstract:For the environmentally aware, natural refrigerant such as CO2 is recommended and pursued by researchers for refrigerators. In this paper, a transcritical CO2 heat pump system was set up to investigate the influence of refrigerant charge on the performance of a small-sized heat pump water heater. The transcritical CO2 heat pump system was composed of a rotary compressor, a tube-in-tube evaporator and gas cooler, an electronic expansion valve (EEV), and an internal heat exchanger (IHX). Based on the experimental results, the effects of refrigerant charge on the key pressures, mass flow rate, power consumption, discharge temperature, superheat, heating capacity and coefficient of performance (COP) were analyzed with different EEV openings. The pressure in the evaporator and gascooler increased with the rise of refrigerant charge. The mass flow rate increased with the refrigerant charge range from 0.6kg to 2.2kg. The experimental results showed that the COP of the system was strongly related to CO2 mass charge and had a maximum value at a specific CO2 mass charge. Undercharged CO2 systems could result in a fast decrease of the heating capacity and COP. The COP reduced more significantly at undercharged conditions than at overcharged conditions as the refrigerant charge further deviated from optimal charge. As EEV opening increased from 40% to 60%, the optimal COP decreased. And with the increase of EEV opening, the corresponding charge amount of optimal COP reduced.

Experimental Study on the Effect of R134A Charge Quantity on the Built-in Refrigerator System

Experimental study on the cycle performance of refrigerant R32

Experimental Investigations on A R134a Ejector Applied in A Refrigeration System

Preliminary study on the performance of the diffusion absorption refrigerator operating with the mixed refrigerant

Experimental Study on the Performances of Small-Sized Heat Pump Water Heater at Different R22 Charge

EXPERIMENTAL RESEARCH ON OPTIMIZATION OF REFRIGERATOR/FREEZER USING HFC-134A AS REFRIGERANT

Development of an automatic charging device for refrigerant mixtures

A STUDY ON THE REFRIGERANT CHARGE OF REFRIGERATOR-FREEZER

Experimental study on the effect of refrigerant charging amount on the performance of CO2-air source heat pump system

Theoretical and experimental researches on a household refrigerator-freezer using R12 and R134a

Impact of Refrigerant Charge on Mobile Air Conditioning System with New Heat Exchanger

Effects of Charge on the Performance of R290 Air Conditioner with Different Expansion Devices

Experimental Study on Throttle Opening in Auto-cascade Refrigeration System

CAPABILITY ANALYSIS OF REFRIGERATION SYSTEM WITH NON-EQUILIBRIUM ADSORPTION

Experimental Studies on an Variable Compositions Auto-Cascade Refrigerator Operating With a Rectifying Column

Experimental Study on New Variable Composition Heat Pump System

Simulations and experiments of substitution of R41 for R23 in auto-cascade refrigeration cycle with rectifying column at -60℃

Coupled Effect of Operation Conditions and Refrigerant Charge on the Performance of a Transcritical CO2 Automotive Air Conditioning System

Investigation on the Influence of Refrigerant Charge Amount on the Cooling Performance of Air Conditioning Heat Pump System for Electric Vehicles

STUDY ON THE ADSORPTION CHARACTERISTICS OF ACTIVATED CARBON-R134a

Investigation on the Influence of Refrigerant Charge on the Performance of Trans-critical CO 2 Water-Water Heat Pump