Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Theoretical Analysis and Experimental Study of Influence of CO Flame on the Combustion of a Char Particle

Characterization on Ignition and Volatile Combustion of Dispersed Coal Particle Streams: in Situ Diagnostics and Transient Modeling

Measurements and Modelling of Oxy-Fuel Coal Combustion

Experimental and theoretical analyses on ignition and surface temperature of dispersed coal particles in O2/N2 and O2/CO2 ambients

A New Flame Sheet Model to Reflect the Influence of the Oxidation of CO on the Combustion of a Carbon Particle

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Modelling the Combustion of Thermally Thick Biomass Particles

Quasi-steady and Transient Combustion of a Carbon Particle: Theory and Experimental Comparisons

Experimental and Modeling Investigation of Oxy-Coal Combustion Based on Langmuir-Hinshelwood Kinetics and Direct Calculation of Char Morphology

Particle Combustion Model Simultaneously Considering A Volatile and Carbon Reaction

Dynamic and kinetic studies on the oxy-coal combustion using multi-parameter high-speed diagnostics

Modeling of Single Coal Particle Combustion in O2/N2 and O2/CO2 Atmospheres under Fluidized Bed Condition

Simulation of Combustion Process for Two Carbon Particles

An Analysis of the Transient Combustion and Burnout Time of Carbon Particles

Optical Investigations on Particles Evolution and Flame Properties During Pulverized Coal Combustion in O2/N2 and O2/CO2 Conditions

Experimental Investigation on Characteristics of Coal Particle Stream Ignition Under Turbulent Condition

THE EFFECT OF FORCED CONVECTION ON MASS AND HEAT TRANSFER DURING SINGLE COAL PARTICLE COMBUSTION

Analysis of Pulverized Coal Flame Stabilized in a 3D Laminar Counterflow

Numerical Simulation Method and Experimental Validation of a Single Char Particle Combustion Model in Bulk Space

Numerical investigation of physicochemical effects of CO2 on coal particle ignition in O2/CO2 ambience

Study on Characteristics of Coal Chars Combustion in O_2/CO_2 at High Temperatures Based a Nonlinear Diffusive Model