Abstract:In order to study the partial discharge (PD) characteristics and evaluate the insulation conditions of the inverter-fed motor under sinusoidal voltage automatically, a set of automatic test system is designed based on high frequency current transformer (HFCT) detection technologies. In the system six high-voltage relays are connected with three-phase windings and the grounded enclosure of the motor. By controlling the six different high-voltage relays (on or off) through the FPGA and with the help of high speed data processing function of DSP, all the partial discharge inception voltage (PDIV) of the phase-to-phase and phase-to-ground insulations can be measured automatically. To verify the test performance of the system, PDIV of twisted pair with polyimide film was measured firstly, and then the phase-to-phase and phase-to-ground insulations of an inverter-fed motor were tested. The results shows: The PDIV of the twisted pairs is about 1.85 kV. The phase-to-phase PDIV of the tested motor is about 3.25 kV, while the PDIV of each phases to ground is obviously higher, reaching more than 5 kV. Compared with traditional test methods, this system can not only measure the PDIV of insulations in the motor automatically, but also greatly reduce the amount of labor and improve test efficiency and accuracy. Therefore, it is especially suitable for testing and evaluating the insulation conditions of large number of motors so as to prevent premature insulation failures and elongate the durability of the motors.

Industrial Computer Control System for Testing Transformer

Industrial Computer Control System for Power Frequency Insulation Test with Testing Voltage Waveform Analysis

Industrial Computer Control System of 2000kv High Voltage Power Frequency Testing Transformer

High Voltage Testing Transformer Computer Control System With Waveform Analysis Function

Application of PLC in safety performance test of compressor

Instrumentation of Online Insulation Monitoring of HV Apparatus

The software design of inverter test system based on VC and NI controls

Development of the Integrated Online-monitoring System for the Insulation of Power Equipment in the Transformer Substation

Realization and application of transformer substation automation test simulation system based on PLC module

An Inverter Testing System for CRAC

Study on the application of an on-line synthetic detecting system for transformer insulation

An Online UHF PD Monitoring System for Power Transformer and Its Applications

Research on Inverter Test System and Performance Analysis

The Test Technology of Electrical Safety Performances Based on IEC International Standards

Restoring over-voltage protection equipment for power frequency insulation experiments

Development of an Intelligentized and MicrocomputizedTransformer Protection Device

PXI-based On-line Monitoring and Analyzing System for Power Transformers

Design of integrated supervisory control system for 110 kV dry-type transformer

An Intensive Care System for Power Transformers

On-line multi-sensor monitoring system for insulation condition of oil-immersed power transformer

The Design Of Automatic Test System Used For Pdiv Measurement Of Inverter-Fed Motor