Abstract:With deep peak-load regulations, utility boilers are frequently operated under variable/low load conditions. However, their hydrodynamics, combustion and NOx emission characteristics are uncertain and relevant theoretical guidance are lacking. For this purpose, a comprehensive CFD model including flow, coal combustion and NOx formation is established for a 630 MW tangentially fired pulverized-coal boiler, aiming at solving the problem of decreasing combustion stability and increasing NOx emission in low-load operation. Based on the grid independence and model validation, the flow field, temperature profile, species concentration profile and NOx emission are predicted, and the influences of angle/arrangement of burners are further evaluated. Simulation results indicate that under low-load conditions, residual airflow rotation still persists at the top of boiler regardless of how to adjust the angle/arrangement of burners. With tilting the burner angle upward, flame is more concentrated, combustion becomes more stable, and heat flux rises in the upper zone; the burner arrangement of ABDE gives more uniform temperature distribution in the combustion zone. CO species shows higher content in the combustion zone; the 0° tilt angle gives maximum CO content, followed by the 15° angle, and finally the −15° angle; compared to the ACDE and ABCE arrangement, the ABDE arrangement mode gives much lower CO contents. Burner tilt angle of −15° benefits for lower NOx emission (183 mg/m3) but goes against stable combustion; the burner arrangement mode of ABDE is optimal for the present boiler, which ensures both stable combustion and lower NOx emission (209 mg/m3).

EXPERIMENT STUDY OF LOW NOX POSITIVE/OPPOSING CONCENTRIC TANGENTIAL FIRING SYSTEM IN A 300 MW PULVERIZED FUEL BOILER

Numerical investigation on oxy-combustion characteristics of a 200MW e tangentially fired boiler

OXYGEN-ENRICHED COMBUSTION IN A HORIZONTAL FURNACE AND THREE- DIMENTIONAL NUMERICAL SIMULATION TEST THEREOF

Numerical Simulations On The Effect Of Over-Fire Air To The Combustion Performance In A 2950 T/H Tangential-Fired Boiler

E305 NUMERICAL SIMULATIONS ON THE EFFECT OF OVER-FIRE AIR TO THE COMBUSTION PERFORMANCE IN A 2950 T/H TANGENTIAL-FIRED BOILER(Boiler-1)

E304 FLOW FIELD IN A MODEL OF A 2950 T/H TANGENTIAL-FIRED BOILER UNDER DIFFERENT CONDITIONS OF SEPARTED OVER-FIRE-AIR INJECTIONS(Boiler-1)

Effects of over Fire Air on the Combustion and Nox Emission Characteristics of A 600 Mw Opposed Swirling Fired Boiler

CONCENTRATED PRIMARY AIR ARRANGEMENT TO MAKE BITUMINITE BURNED BOILER SLAGGING - PREVENT AND LOW NOx RELEASE

Numerical and experimental investigation on the reduction of NOx emission in a 600 MW utility furnace by using OFA

Tertiary-air Effects on Combustion and NOx Emission in Tangentially Fired Furnace

Experimental and Numerical Investigation of NOx Emissiion Property in a 600MW Utility Boiler with Deflected Second Air System

Numerical Simulation of the NOx Emissions in a 1000 MW Tangentially Fired Pulverized-Coal Boiler: Influence of the Multi-group Arrangement of the Separated over Fire Air

STUDY ON NUMERICAL SIMULATION OF DECREASING NOx EMISSION FROM COAL-FIRED BOILERS BASED ON BFA AND OFA

Numerical and experimental investigations on the performance of a 300 MW pulverized coal furnace

Study on Low NOx Optimimal Operation of a Tangentially Fired Boiler under Variable Parameters

CFD modeling of hydrodynamics, combustion and NOx emission in a tangentially fired pulverized-coal boiler at low load operating conditions

Influence of Separated Overfire Air Ratio and Location on Combustion and NOx Emission Characteristics for a 600 MWe Down-Fired Utility Boiler with a Novel Combustion System

Numerical investigation on the optimized arrangement for high-temperature corrosion after low NOx transformation

Flow Field In A Model Of A 2950 T/H Tangential-Fired Boiler Under Different Conditions Of Separted Over-Fire-Air Injections

Tertiary air operation optimization aiming at low NOx combustion in boiler

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air