Abstract:Introduction Efficiency improvements in flexible DSSCs are expected by employing tailor-made ZnO. We have developed a method to quickly crystallize ZnO by microwave assisted hydrothermal reactions. Structures of these nanocrystals for shapes and sizes, as well as preferentially exposed crystal facets, could significantly influence key parameters such as dye adsorption capability and electron transporting property. Experiment Microwave radiation to aqueous solution containing Zn(CH3COO)2 and structure directing agents (SDAs) such as triethanolamine (TEOA) and 1,2,4,5benzenetetracarboxylic acid (BTCA) with controlled pH by addition of KOH resulted in formation of ZnO. The precipitates were centrifuged, washed and dried in an oven for 12h. Dye adsorption capability was estimated from the amount of D149 dye at saturation after stirring ZnO powder added to D149 solution for 24h. Result and Discussion Well crystallized ZnO but totally different morphology was obtained by using TEOA or BTCA (Fig. 1). Use of TEOA resulted in nanoparticles with hexagonal and bipyramidal (HBP) shape in about 50 to 100 nm size. TEM observation combined with SAED confirmed that the axis connecting two tips of HBP corresponds to the caxis of ZnO. While the rectangular sides in 6-fold symmetry obviously correspond to (100), the triangular facets could possibly be (101), (102) or (103). The angle between ridges and the horizontal line of HBP fell in the range between 38 and 41 from SEM images, so that the triangle is most likely (102) with its occupancy to the total surface area of ca. 84%. On the other hand, the use of BTCA resulted in formation of nano-sheet (NS) ZnO. TEM, SAED and lattice images of NS identified that the mainly exposed facets are of the (100) planes of ZnO. Surface area and D149 adsorption capability were checked for the synthesized ZnO in HBP and NS shapes in comparison with a commercial ZnO. Large difference was found for the area occupied by a D149 molecule as 2.4 (commercial), 0.99 (HBP) and 0.59 (NS) nm, indicating differences of dye adsorption stability for different facets. Their differences in DSSC properties are also studied and discussed. Fig. 1 SEM pictures and imagination structures of differently ZnO nanoparticles.

Controlled Synthesis of Nano-ZnO with Different Morphologies by Hydrolysis in Water Bath/in Microwave with Different Frequency

Microwave-Assisted Rapid Synthesis Of Zno Hexagonal Quasi-Hourglasses

Morphology Investigation of Hydrothermally Prepared ZnO Micro-Crystals Influenced by Cu2+ Ions

Controlled Synthesis of 1D ZnO Nanostructures Via Hydrothermal Process

Conversion of large-scale oriented ZnO rod array into nanotube array under hydrothermal etching condition via one-step synthesis approach

Synthesis and electromagnetic characteristics of ZnO micro-crystal with varying morphology

Sequential Occurrence of ZnO Nanopaticles, Nanorods, and Nanotips During Hydrothermal Process in a Dilute Aqueous Solution

Shape-Controlled Synthesis of Mnwo4 Nanocrystals by A Surfactant-Free Hydrothermal Method

Synthesis of morphology-controlled ZnO microstructures via a microwave-assisted hydrothermal method and their gas-sensing property.

Low-temperature growth of uniform ZnO particles with controllable ellipsoidal morphologies and characteristic luminescence patterns.

Facile and Controllable Growth of ZnO 1D Nanostructure Arrays on Zn Substrate by Hydrothermal Process

Hydrothermal Synthesis of Well-Aligned ZnO Nanorod Arrays on Silicon

Microwave Synthesis of ZnO Nano Crystals for Dye-sensitized Solar Cells

Controlled Synthesis Of The Znwo4 Nanostructure And Effects On The Photocatalytic Performance

Controllable microwave and ultrasonic wave combined synthesis of ZnO micro-/nanostructures in HEPES solution and their shape-dependent photocatalytic activities

Preparation and Photoluminescence of ZnO with Nanostructure by Hollow-Cathode Discharge

Controllable Synthesis of Hexagonal, Bullet-Like Zno Microstructures and Nanorod Arrays and Their Photocatalytic Property

Influence of Microwave Hydrothermal Conditions on the Morphology and Particle Size of Zinc Oxide Crystailite

Morphology Controlling and Optical Property of ZnO Prepared by Hydrothermal Method

Controllable Growth of ZnO Microcrystals by a Capping-Molecule-Assisted Hydrothermal Process

Preparation of Nano-ZrO2 powder via a microwave-assisted hydrothermal method