Pilot study on advanced treatment of Nansi Lake water by UF-NF hybrid membrane process

Xuewu Zhu,Min Dang,Zhendong Gan,Xing Du,Fangshu Qu,Heng Liang,Guibai Li
DOI: https://doi.org/10.3969/j.issn.1002-8471.2018.03.006
2018-01-01
Abstract:To remove the high organic pollutants and high salt ions of Nansi Lake water,a pilot study was conducted using ultrafiltration-nanofiltration process,and the treatment efficiency of two kinds of NF membrane (H membrane and G membrane)were compared.Experimental results show that the UF-NF hybrid system can remove organic matter and inorganic salt ions effectively. The inorganic salt ions removal rate of the two NF membranes was both above 90% and the DOC removal rate of H membrane and G membrane were 98.7% and 81.6%,respectively.By contrast, the effluent water quality of H membrane was much better than that of G membrane.The mem-brane flux of G membrane was higher than that of H membrane under the same condition (pressure and temperature),and the energy consumption of G membrane was lower than that of H mem-brane.At the inlet side of fouled NF membrane,the main fouling was organic pollution,while it was mainly inorganic salt scale at the outlet side.The membrane flux could be restored to more than 90% of the initial flux by chemical cleaning.However,there were still traces of organic mat-ter and inorganic salts on the membrane surface after cleaning,which was the main reason for the irreversible NF membrane fouling.
What problem does this paper attempt to address?