Effect of pH on Hydrogen Production during Anaerobic Fermentation of Kitchen Waste

袁雨珍,肖利平,刘传平,窦飞

DOI: https://doi.org/10.16258/j.cnki.1674-5906.2017.04.021

2017-01-01

Abstract:Due to the characteristics of kitchen waste such as high moisture content, high organic matter content, and easily for decomposition, inappropriate management of kitchen waste can cause a waste of resources and pollution to the environment. More and more attention has been paid to the reduction, harmlessness and recycling treatment of kitchen waste in recent years. In order to reduce the kitchen waste as well as produce clean energy such as hydrogen gas, the effect of pH on hydrogen production during anaerobic fermentation of steamed kitchen waste was investigated in a sequencing batch anaerobic fermentation reactor inoculated with residual sludge from wastewater treatment plant, with a substrate/inoculum ratio of 4/1 and an inoculation temperature of 37 ℃. Butyric acid and acetic acid were the most important components in the substrate, which accounted for more than 80% of the total volatile acid, and there was only a small amount of propionic acid. This suggested that it was a typical type of butyric acid fermentation process. The results showed that the optimized initial pH was 9.0, which lead to the maximum cumulative gas production rate of 748 mL and the maximum hydrogen production quantity of 371 mL. In the whole process of anaerobic fermentation, the highest hydrogen volume fraction was up to 80.5%, and the average hydrogen production rate and unit capacity of hydrogen (VS) was 10.31 mL·h-1and 72.9 mL·g-1, respectively. The removal rate of VS and TS was up to 26.6% and 34.4%, respectively. The activity of dehydrogenase increased during 0~16 h and then decreased gradually over time, which was positively related to the hydrogen production when the initial pH was 9.0. The highest activity of dehydrogenase was detected at 16 h, when the maximum hydrogen production rate was achieved as 19.2 mL·h-1. Therefore, the efficiency of hydrogen production from anaerobic fermentation of kitchen waste can be improved by adjusting the initial pH, which can provide useful information for the application of clean energy production during reduction of the kitchen waste.