Abstract:Continuous spill fires pose significant risks to the storage and transportation industries of liquid fuels. To investigate the flame length and pulsation behavior of continuous spill fires, large-scale spill fire experiments were conducted on water to simulate the burning fuel on a water surface that could occur during firefighting of tank fires or due to leaked fuels on water during transportation, with varying discharge rates (3, 6, 9, 14 mL/s) and ignition delays (0, 10, 20, 30 s). The results suggest that the flame length increased initially with the spread area and reached the maximum at the end of the spreading stage, then followed by a decrease at the shrinking stage and kept nearly constant at the steady stage. For the steady flame length, a new correlation (L-s /D = 3.1((Q) over dot*)(0.42)) was established based on dimensionless analysis, which was higher than that for pool fires, high-lighting the important differences between spill and pool fires. This developed model was also used to predict the maximum flame length with a maximum deviation of 19.2%, as the heat transfer mechanism and air entrainment are expected to be similar at the shrinking and steady stages. The flame pulsation frequency was determined through the fast Fourier transform (FFT) method, which shows a gradual decrease during the spreading stage while remaining higher than that of pool fires at the steady stage. Subsequently, two new correlations (f(i) = 0.525 root g/D and f(s) = 0.724 root g/D) were derived from experimental data to predict the pulsation frequency at both spreading and steady stages. The higher frequencies during the steady stage can have a significant influence on the radiation impact to adjacent equipment or personnel. This study not only provides insights into the flame and pulsation behaviors of spill fires but lays a solid foundation for the thermal hazard and risk assessment analysis in the liquid fuel storage and transportation industries.

Experimental study on spreading characteristics of jet fuel spill fire

Experiments Investigating Fuel Spread Behaviors for Continuous Spill Fires on Fireproof Glass

Large-Scale Experimental Study on the Spread and Burning Behavior of Continuous Liquid Fuel Spill Fires on Water

Experimental Study on the Effect of Sub-Flash Point Fuel Temperature on the Spread Characteristics of Spill Fire

Experimental Study on the Liquid Layer Spread and Burning Behaviors of Continuous Heptane Spill Fires

Effect of Substrate Slope on the Aviation Kerosene Spill Fires

Experimental Study of Continuously Released Liquid Fuel Spill Fires on Land and Water in a Channel

Experimental study on continuous spill fire of liquid fuel on porous bed

An experimental study on the spreading characteristics and burning behaviors of continuous spill fires under cross flow

An Experimental and Modeling Study of Continuous Liquid Fuel Spill Fires on Water

Experimental investigation and modeling of the spread and burning behaviors of continuous spill fires on a water surface

Experimental Study on Spread and Burning Characteristics of Continuous Spill Fire Leaked from a Point Source under Different Slopes

An Experimental Study on the Spread of Burning Gasoline Spilling on Water

Experimental Study on Flame Length and Pulsation Behavior of N-Heptane Continuous Spill Fires on Water

Experimental Study on the Spread and Burning Behaviors of Continuously Discharge Spill Fires under Different Slopes.

Experimental investigation on flame characteristics in a linear array of dual spill fire

An Experimental Study on the Burning Rate of a Continuously Released N-Heptane Spill Fire on an Open Water Surface

Experimental Study on the Ignition Characteristics of Leaking RP-3 Aviation Kerosene on a Horizontal Hot Wall

An experimental investigation into the effect of substrate slope on the continuously released liquid fuel spill fires

Experimental and Modeling Study of the Behavior of A Large-Scale Spill Fire on A Water Layer

Experimental investigation on flame spread over jet fuel with influence of external heat radiation